Gas-liquid two-phase flow in horizontal channel under nonlinear vibration

ZHOU Yunlong; CHANG He; LIU Qichao

doi:10.11949/0438-1157.20190250

您当前的位置：

首页 >

文章列表页 >

Gas-liquid two-phase flow in horizontal channel under nonlinear vibration

Fluid dynamics and transport phenomena | 更新时间：2026-07-24

- Gas-liquid two-phase flow in horizontal channel under nonlinear vibration
- CIESC Journal Vol. 70, Issue 7, Pages: 2512-2519(2019)
- 作者机构：
  
  东北电力大学能源与动力工程学院，吉林省吉林市 132012
- 作者简介：
- 基金信息：
- DOI：10.11949/0438-1157.20190250
  CLC： TB 123
- Received：18 March 2019，
  
  Revised：2019-04-24，
  
  Online First：24 July 2026，
  
  Published：05 July 2019
- 稿件说明：
移动端阅览
周云龙, 常赫, 刘起超. 非线性振动下水平通道气液两相流动[J]. 化工学报, 2019, 70(7): 2512-2519

ZHOU Yunlong, CHANG He, LIU Qichao. Gas-liquid two-phase flow in horizontal channel under nonlinear vibration[J]. CIESC Journal, 2019, 70(7): 2512-2519
周云龙, 常赫, 刘起超. 非线性振动下水平通道气液两相流动[J]. 化工学报, 2019, 70(7): 2512-2519 DOI： 10.11949/0438-1157.20190250.

ZHOU Yunlong, CHANG He, LIU Qichao. Gas-liquid two-phase flow in horizontal channel under nonlinear vibration[J]. CIESC Journal, 2019, 70(7): 2512-2519 DOI： 10.11949/0438-1157.20190250.

摘要

将振动装置与气液两相流实验回路相结合，对非线性振动工况下水平通道内气液两相流进行实验研究。重点考察了不同振动参数对流型转换界限及摩擦压降的影响。流型图表明，非线性振动工况和稳态工况下的气液两相流动形式不同，提高振动的频率和幅度会导致流型转换界限发生改变。由实验得到的气液界面分布结果表明，振动频率对相界面波动程度有显著影响，而振动幅度则主要影响截面含气率。最后对比了非线性振动工况下的摩擦压降和经验公式的计算结果，发现两者在数值和分布上均无明显差异，说明稳态下两相流摩擦压降计算公式同样适用于非线性振动工况。

Abstract

The vibrating device is combined with the gas-liquid two-phase flow experimental loop to carry out experimental research on the gas-liquid two-phase flow in the horizontal channel under nonlinear vibration conditions. The influences of various vibration parameters on flow regime transition line and frictional pressure drop were analyzed. The flow transition boundary diagrams illustrate that flow conditions under nonlinear vibration is different from that under steady state. The whole flow pattern has an outward expansion tendency with the slug flow as the center as vibration frequency or amplitude increases. Vibration frequency has a significant effect on fluctuation degree of gas-liquid interphase

whereas vibration amplitude mainly affects void fraction. There was no obvious difference on the values and distribution between the calculation deviations in fluid flow under nonlinear vibration and the calculation deviations in fluid flow under steady state by using different empirical formulas. The results show that the empirical correlations for frictional pressure drop of two-phase flow under steady state are also suitable for the calculation of frictional pressure drop of gas-liquid two-phase flow under nonlinear vibration.

关键词

Keywords

references

刘国强 , 孙立成 , 阎昌琪 . 竖直圆管内泡状流界面参数分布特性 [J ] . 原子能科学技术 , 2014 , 48 ( 7 ): 1176 - 1181 .

Liu G Q , Sun L C , Yan C Q . Interfacial parameter distribution of bubbly flow in vertical circular tube [J ] . Atomic Energy Science and Technology , 2014 , 48 ( 7 ): 1176 - 1181 .

Ishida T , Yoritsune T . Effects of ship motions on natural circulation of deep sea research reactor DRX [J ] . Nuclear Engineering and Design , 2002 , 215 ( 1 / 2 ): 51 - 67 .

Humphries J R , Davies D . A floating desalination/ co-generation system using the KLT-40 reactor and Canadian RO desalination technology [C ] //Proceedings of Advisory Group Meeting. Vienna: International Atomic Energy Agency , 1998 .

Panov Y K , Polunichev V I , Zverev K V . Nuclear floating power desalination complexes [C ] //Proceedings of Four Technical Meeting. Vienna: International Atomic Energy Agency , 1998 .

峦峰 , 阎昌琪 . 摇摆状态下水平管内气-水两相流的流型研究 [J ] . 核动力工程 , 2007 , 28 ( 2 ): 19 - 23 .

Luan F , Yan C Q . Study on the flow pattern of gas water two phase flow in a horizontal pipe in a swing state [J ] . Nuclear Power Engineering , 2007 , 28 ( 2 ): 19 - 23 .

Tan S C , Wang Z W , Chang W , et al . Flow fluctuations and flow friction characteristics of vertical narrow rectangular channel under rolling motion conditions [J ] . Experimental Thermal and Fluid Science , 2013 , 50 : 69 - 78 .

Chen S W , Liu Y , Hiniki T . Experimental study of air-water two-phase flow in an 8×8 rod bundle under pool condition for one-dimensional drift-flux analysis [J ] . International Journal of Heat and Fluid Flow , 2012 , 33 ( 1 ): 168 - 181 .

马晓旭 , 田茂诚 , 张冠敏 . 水平管内气液两相流诱导振动的数值模拟 [J ] . 振动与冲击 , 2016 , 35 ( 16 ): 204 - 210 .

Ma X X , Tian M C , Zhang G M . Numerical investigation on gas-liquid two-phase flow-induced vibration in a horizontal tube [J ] . Journal of Vibration and Shock , 2016 , 35 ( 16 ): 204 - 210 .

李金辉 , 卢剑伟 , 姜俊昭 . 液体晃动对槽罐车摆振系统动力学响应的影响分析 [J ] . 振动与冲击 , 2018 , 37 ( 2 ): 135 - 141 .

Li J H , Lu J W , Jiang J Z . Analysis of tank truck shimmy with consideration of liquid sloshing [J ] . Journal of Vibration and Shock , 2018 , 37 ( 2 ): 135 - 141 .

陈冲 , 高濮珍 . 摇摆工况下窄矩形通道内两相沸腾摩擦压降特性 [J ] . 化工学报 , 2015 , 66 ( 2 ): 3874 - 3880 .

Chen C , Gao P Z . Frictional pressure drop characteristics of two-phase boiling in narrow rectangular channel under swing condition [J ] . CIESC Journal , 2015 , 66 ( 2 ): 3874 - 3880 .

周世忠 , 朱琳 , 张阳波 . 大流量下倾斜管内气液两相流实验研究 [J ] . 当代化工 , 2016 , 45 ( 3 ): 504 - 506 .

Zhou S Z , Zhu L , Zhang Y B . Experimental study of two-phase flow in inclined pipe under high gas-liquid flow [J ] . Contemporary Chemical Industry , 2016 , 45 ( 3 ): 504 - 506 .

周云龙 , 李珊珊 . 起伏振动状态下倾斜管内两相流多尺度熵分析 [J ] . 化工学报 , 2018 , 69 ( 5 ): 1884 - 1891 .

Zhou Y L , Li S S . Multi-scale entropy analysis of two-phase flow in inclined pipe under vibration condition [J ] . CIESC Journal , 2018 , 69 ( 5 ): 1884 - 1891 .

Talley J D , Worosz T , Kim S . Characterization of horizontal air-water two-phase flow in a round pipe (Ⅱ): Measurement of local two-phase parameters in bubbly flow [J ] . International Journal of Multiphase Flow , 2015 , 76 : 223 - 236 .

肖秀 , 朱庆子 , 王冠轶 . 振动工况下环管内气液两相流参数分布实验研究 [J ] . 原子能科学技术 , 2017 , 51 ( 1 ): 19 - 25 .

Xiao X , Zhu Q Z , Wang G Y . Experiment investigation on two-phase flow parameter distribution in annular channel under vibration condition [J ] . Atomic Energy Science and Technology , 2017 , 51 ( 1 ): 19 - 25 .

Pendayala R , Jayatin S , Balkrishinan A R . Convective heat transfer in single-phase flow in a vertical tube to axial low frequency oscillations [J ] . Heat Mass Transfer , 2008 , 44 : 857 - 864 .

Pendayala R , Jayatin S , Balkrishinan A R . Flow and pressure drop fluctuations in vertical tube subject to low frequency oscillations [J ] . Nuclear Engineering and Design , 2008 , 238 ( 1 ): 178 - 187 .

周云龙 , 尹洪梅 , 丁会晓 . 多尺度熵在棒束通道气液两相流压差信号分析中的应用 [J ] . 化工学报 , 2016 , 67 ( 9 ): 3625 - 3632 .

Zhou Y L , Yin H M , Ding H X . Application of multi-scale entropy in analyzing pressure difference signals of gas-liquid two-phase flow in rod bundled channel [J ] . CIESC Journal , 2016 , 67 ( 9 ): 3625 - 3632 .

丁浩 , 黄志尧 , 李海青 . 气液两相流压差波动的Hilbert-Huang变换特性 [J ] . 化工学报 , 2005 , 56 ( 12 ): 2294 - 2302 .

Ding H , Huang Z Y , Li H Q . Property of differential pressure fluctuation signal of gas-liquid two-phase flow based on Hilbert-Huang transform [J ] . Journal of Chemical Industry and Engineering (China) , 2005 , 56 ( 12 ): 2294 - 2302 .

Chen S W , Hibiki T , Ishimi M . Experimental study of adiabatic two-phase flow parameter in an annular channel under low-frequency vibration [J ] . Journal of Engineering for Gas Turbines and Powers , 2014 , 136 : 032501 .

周云龙 , 赵盘 , 杨宁 . 振动状态下水平管内气液两相流流型转变的实验研究 [J ] . 热能动力工程 , 2017 , 32 ( 6 ): 617 - 22 .

Zhou Y L , Zhao P , Yang N . Experimental study on flow pattern transition of gas liquid two-phase in horizontal tubes under vibration condition [J ] . Journal of Engineering for Thermal Energy and Power , 2017 , 32 ( 6 ): 17 - 22 .

周云龙 , 李珊珊 . 起伏振动状态下倾斜管内气液两相流型实验研究 [J ] . 原子能科学技术 , 2018 , 5 ( 2 ): 262 - 268 .

Zhou Y L , Li S S . Experiment investigation on gas-liquid two-phase flow pattern in inclined pipe under fluctuant vibration condition [J ] . Atomic Energy Science and Technology , 2018 , 52 ( 2 ): 262 - 268 .

Ran K , Kim W , Bajorek S . Effects of pipe size on horizontal two-phase flow: flow regimes, pressure drop, two-phase flow parameters, and drift-flux analysis [J ] . Experimental Thermal and Fluid Science , 2018 , 96 : 75 - 89 .

Mandhane J M , Gregory A , Asis K . A flow pattern map for gas-liquid flow in horizontal pipes [J ] . International Journal of Multiphase Flow , 1974 , 1 : 537 - 553 .

Gang H , Xiao Y . Experimental research of bubble characteristics in narrow rectangular channel under heaving motion [J ] . International Journal of Thermal Sciences , 2012 , 51 : 42 - 50 .

刘建华 , 王宏光 , 韩铁鹰 . 管内壁面振动对流场与传热影响的模拟研究 [J ] . 热能动力工程 , 2017 , 32 (S 1 ): 14 - 20 .

Liu J H , Wang H G , Han T Y . Numerical study of the influences of wall vibration on the flow and heat exchange in tube [J ] . Journal of Engineering for Thermal Energy and Power , 2017 , 32 (S 1 ): 14 - 20 .

Catalina P , Pailo W . Effect of forced flow oscillations on churn and annular flow in a long vertical tube [J ] . Experimental Thermal and Fluid Science , 2017 , 81 : 345 - 357 .

贾辉 , 谭思超 , 高濮珍 . 不稳定条件下水平管单相水流动阻力特性实验研究 [J ] . 原子能科学技术 , 2011 , 45 ( 2 ): 168 - 173 .

Jia H , Tan S C , Gao P Z . Experimental study on horizontal single phase water flow resistance characteristics under unsteady flow condition [J ] . Atomic Energy Science and Technology , 2011 , 45 ( 2 ): 468 - 173 .

Lockhart R W , Martinelli R C . Proposed correlation of data for isothermal two-phase, two-component flow in pipes [J ] . Chemical Engineering Progress , 1949 , 45 : 39 - 48 .

Chisholm D . A theoretical basis for the Lockhart-Martinelli correlation for two-phase flow [J ] . International Journal of Heat and Mass Transfer , 1967 , 10 : 1767 - 1778 .

Akagawa K . The flow of the mixture of air and water(Ⅲ):The friction drops in horizontal, inclined and vertical tubes [J ] . Transactions of Japan Society Mechanical Engineering , 1957 , 23 : 292 - 298 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Study on boiling characteristics of liquid crystal elastomer surfaces with thermally adaptive wettability

Effect of screen on multiscale bubble dynamics and mass transfer characteristics in loop reactor

Prediction of void fraction in gas-liquid two-phase flow under fluctuating vibration in horizontal and vertical pipes based on WOA-CNN-GRU-ATT

Dispersion characteristics of charged bubbles in an electric dispersion tubular packed bed

Study on flow and cavitation characteristic in zigzag and array labyrinth valve core structures

Related Author

CHEN Shuai

HU Yanwei

LIU Zihe

JIA Shaokun

GUO Kai

ZHAO Yin

ZHANG Ya’nan

LEI Qing

Related Institution

School of Energy Science Engineering, Harbin Institute of Technology

Suzhou Research Institute, Harbin Institute of Technology

School of Chemical Engineering and Technology, Tianjin University

Hubei Institute of Aerospace Chemotechnology, Xiangyang

National Key Laboratory of Aerospace Chemical Power, Xiangyang

⁰