Study on removal characteristics of organic dyes by tight GO/PVDF composite membranes

ZHU Zhenya; BAI Chengling; WANG Lei; MENG Xiaorong

doi:10.11949/0438-1157.20181479

您当前的位置：

首页 >

文章列表页 >

Study on removal characteristics of organic dyes by tight GO/PVDF composite membranes

Material science and engineering\, nanotechnology | 更新时间：2026-07-24

- Study on removal characteristics of organic dyes by tight GO/PVDF composite membranes
- CIESC Journal Vol. 70, Issue 6, Pages: 2361-2369(2019)
- 作者机构：
  
  1.西安建筑科技大学环境与市政工程学院，陕西省膜分离技术研究院，陕西省膜分离重点实验室，陕西省环境工程重点实验室，陕西西安 710055
  2.河北地质大学水资源与环境学院，河北省水资源可持续利用与开发重点实验室，河北省水资源可持续利用与产业结构优化协同创新中心，河北石家庄 050031
- 作者简介：
- 基金信息：
- DOI：10.11949/0438-1157.20181479
  CLC： TQ 028.8
- Received：14 December 2018，
  
  Revised：2019-03-19，
  
  Online First：15 June 2020，
  
  Published：05 June 2019
- 稿件说明：
移动端阅览
朱振亚, 白成玲, 王磊, 孟晓荣. 紧实型GO/PVDF复合膜对有机染料的去除性能研究[J]. 化工学报, 2019, 70(6): 2361-2369

ZHU Zhenya, BAI Chengling, WANG Lei, MENG Xiaorong. Study on removal characteristics of organic dyes by tight GO/PVDF composite membranes[J]. CIESC Journal, 2019, 70(6): 2361-2369
朱振亚, 白成玲, 王磊, 孟晓荣. 紧实型GO/PVDF复合膜对有机染料的去除性能研究[J]. 化工学报, 2019, 70(6): 2361-2369 DOI： 10.11949/0438-1157.20181479.

ZHU Zhenya, BAI Chengling, WANG Lei, MENG Xiaorong. Study on removal characteristics of organic dyes by tight GO/PVDF composite membranes[J]. CIESC Journal, 2019, 70(6): 2361-2369 DOI： 10.11949/0438-1157.20181479.

摘要

采用氧化石墨烯(GO)改性PVDF膜，利用浸没沉淀相转化的方法制备了紧实型GO/PVDF复合膜，对膜的亲水

性、纯水通量和表面Zeta电位等性能进行了考察，并选择罗丹明B和甲基橙分别代表正负电荷染料，对膜的吸附、脱附和截留性能进行了考察。结果显示，膜的纯水通量从45.10 L/(m

·h)增加到58.40 L/(m

·h)。GO含量为0.50%(质量)时(M2)，膜的综合性能较优。GO/PVDF复合膜对罗丹明B的吸附效果较好，1.5 d之后，M0~M3的吸附量分别为1.02、1.24、1.79和1.49 mg/g。乙醇对罗丹明B的脱色率达到80%以上。膜对甲基橙的吸附效果较差，M2的吸附量仅为0.46 mg/g，0.10 mol/L HCl溶液对甲基橙脱色率达到86%以上。膜对两种染料的截留率均保持在57.60%和57.20%以上。为纳米材料改性有机膜的制备以及对有机染料的去除提供了一定的科学依据。

Abstract

The PVDF membrane was modified by graphene oxide (GO)

and the compacted GO/PVDF composite membrane was prepared by immersion precipitation phase transformation. The hydrophilicity

pure water flux and surface zeta potential of the membrane were investigated. Rhodamine B and methyl orange were selected as positive and negative charge dyes to investigate the adsorption

desorption and retention properties of membranes. The results showed that the pure water flux of membrane increased from 45.10 L/(m

·h) to 58.40 L/(m

·h). When the content of GO was 0.50%(mass) (M2)

the comprehensive performance of membrane was better. GO/PVDF composite membranes had a good adsorption effect on Rhodamine B. After 1.5 d

the adsorption capacity of M0—M3 were 1.02

1.24

1.79 and 1.49 mg/g respectively. The decolorization rate of Rhodamine B by ethanol was over 80%. The adsorption capacity of M2 was only 0.46 mg/g

and decolorization rate of methyl orange by 0.10 mol/L HCl solution was over 86%. The retention rates of two dyes remained above 57.60% and 57.20%. This study provided a scientific basis for the preparation of nano-materials modified membranes and their characteristics of organic dye removal.

关键词

Keywords

references

Yagub M T , Sen T K , Afroze S , et al . Dye and its removal from aqueous solution by adsorption: a review [J ] . Advance in Colloid Interface Science , 2014 , 209 : 172 - 184 .

Verma A K , Dash R R , Bhunia P . A review on chemical coagulation/flocculation technologies for removal of colour from textile wastewaters [J ] . Journal Environment Management , 2012 , 93 : 154 - 168 .

Nidheesh P V , Gandhimathi R , Ramesh S T . Degradation of dyes from aqueous solution by Fenton processes: a review [J ] . Environmental Science Pollution Research , 2013 , 20 : 2099 – 2132 .

Blanco J , Torrades F , Moron M , et al . Photo-Fenton and sequencing batch reactor coupled to photo-Fenton processes for textile wastewater reclamation: feasibility of reuse in dyeing processes [J ] . Chemical Engineering Journal , 2014 , 240 : 469 - 475 .

Wei X , Kong X , Sun C , et al . Characterization and application of a thin-film composite nanofiltration hollow fiber membrane for dye desalination and concentration [J ] . Chemical Engineering Journal , 2013 , 223 : 172 – 182 .

Ayyaru S , Ahn Y H . Application of sulfonic acid group functionalized graphene oxide to improve hydrophilicity, permeability, and antifouling of PVDF nanocomposite ultrafiltration membranes [J ] . Journal Membrane Science , 2017 , 525 : 210 - 219 .

Mahmoudi E , Ng L Y , B M M , et al . Novel nanohybrid polysulfone membrane embedded with silver nanoparticles on graphene oxide nanoplates [J ] . Chemical Engineering Journal , 2015 , 277 : 1 - 10 .

Barredo D S , Alcaina M I , Bes P A , et al . Ceramic membrane behavior in textile wastewater ultrafiltration [J ] . Desalination , 2010 , 250 : 623 – 628 .

Koseoglu D Y . The determination of performances of polysulfone (PS) ultrafiltration membranes fabricated at different evaporation temperatures for the pretreatment of textile wastewater [J ] . Desalination , 2013 , 316 : 110 - 119 .

Lin J Y , Ye W Y , Baltaru M C , et al . Tight ultrafiltration membranes for enhanced separation of dyes and Na 2 SO 4 during textile wastewater treatment [J ] . Journal of Membrane Science , 2016 , 514 : 217 – 228 .

Kajekar A J , Dodamani B M , Isloor A M , et al . Preparation and characterization of novel PSf/PVP/PANI-nanofiber nanocomposite hollowfiber ultrafiltration membranes and their possible applications for hazardous dye rejection [J ] . Desalination , 2015 , 365 : 117 – 125 .

Kang G D , Cao Y M . Application and modification of poly(vinylidene fluoride) (PVDF) membranes — a review [J ] . Journal of Membrane Science , 2014 , 463 ( 1 ): 145 - 165 .

Srivastava H P , Arthanareeswaran G , Anantharaman N , et al . Performance of modified poly (vinylidene fluoride) membrane for textile wastewater ultrafiltration [J ] . Desalination , 2011 , 282 : 87 – 94 .

Zhu Z Y , Jiang J L , Wang X D , et al . Improving the hydrophilic and antifouling properties of polyvinylidene fluoride membrane by incorporation of novel nanohybrid GO@SiO 2 particle [J ] . Chemical Engineering Journal , 2017 , 314 : 266 - 276 .

Efome J E , Rana D , Matsuura T , et al . Enhanced performance of PVDF nanocomposite membrane by nanofiber coating: a membrane for sustainable desalination through MD [J ] . Water Research , 2016 , 89 : 39 - 49 .

Shi H , He Y , Pan Y , et al . A modified mussel-inspired method to fabricate TiO 2 decorated super hydrophilic PVDF membrane for oil/water separation [J ] . Journal of Membrane Science , 2016 , 506 : 60 - 70 .

Liu F , Abed M R M , Li K J . Preparation and characterization of poly (vinylidene fluoride) (PVDF) based ultrafiltration membranes using nano γ-Al 2 O 3 [J ] . Journal of Membrane Science , 2011 , 366 : 97 - 103 .

Chang X , Wang Z , Quan S , et al . Exploring the synergetic effects of graphene oxide (GO) and polyvinylpyrrodione (PVP) on poly(vinylylidenefluoride) (PVDF) ultrafiltration membrane performance [J ] . Appling Surface Science , 2014 , 316 : 537 - 548 .

Isaji S , Bin Y , Matsuo M . Electrical conductivity and self-temperature-control heating properties of carbon nanotubes filled polyethylene films [J ] . Polymer , 2009 , 50 : 1046 - 1053 .

Ganesh B M , Isloor A M , Ismail A F . Enhanced hydrophilicity and salt rejection study of graphene oxide-polysulfone mixed matrix membrane [J ] . Desalination , 2013 , 313 : 199 - 207 .

Celik E , Park H , Choi H , et al . Carbon nanotube blended polyethersulfone membranes for fouling control in water treatment [J ] . Water Research , 2011 , 45 : 274 - 282 .

Jadav G L , Singh P S . Synthesis of novel silica-polyamide nanocomposite membrane with enhanced properties [J ] . Journal of Membrane Science , 2009 , 328 : 257 - 267 .

Hwang T , Kotte M R , Han J I , et al . Microalgae recovery by ultrafiltration using novel fouling-resistant PVDF membranes with in situ PEGylated polyethyleneimine particles [J ] . Water Research , 2015 , 73 : 181 - 192 .

Liu X H , Duan J , Yang J H , et al . Hydrophilicity, morphology and excellent adsorption ability of poly (vinylidene fluoride) membranes induced by graphene oxide and polyvinylpyrrolidone [J ] . Colloids and Surfaces A: Physicochemical Engineering Aspects , 2015 , 486 : 172 – 184 .

Marcano D C , Kosynkin D V , Berlin J M , et al . Improved synthesis of graphene oxide [J ] . ACS Nano , 2010 , 4 : 4806 - 4814 .

Kiran S A , Thuyavan Y L , Arthanareeswaran G , et al . Impact of graphene oxide embedded polyethersulfone membranes for the effective treatment of distillery effluent [J ] . Chemical Engineering Journal , 2016 , 286 : 528 – 537 .

Cui Z L , Hassankiadeh N T , Zhuang Y B , et al . Crystalline polymorphism in poly (vinylidene fluoride) membranes [J ] . Progress Polymer Science , 2015 , 51 : 94 – 126 .

Meng N , Rebecca C E P , Zhang Y , et al . The effect of reduction degree of GO nanosheets on microstructure and performance of PVDF/GO hybrid membranes [J ] . Journal Membrane Science , 2016 , 501 : 169 – 178 .

Wang Z , Yu H , Xia J , et al . Novel GO-blended PVDF ultrafiltration membranes [J ] . Desalination , 2012 , 299 : 50 - 54 .

Li Z K , Lang W Z , Miao W , et al . Preparation and properties of PVDF/SiO 2 @GO nanohybrid membranes via thermally induced phase separation method [J ] . Journal Membrane Science , 2016 , 511 : 151 - 161 .

Aouni A , Fersi C , Cuartas U B , et al . Reactive dyes rejection and textile effluent treatment study using ultrafiltration and nanofiltration processes [J ] . Desalination , 2012 , 297 : 87 – 96 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Preparation of composite nanofiltration membrane with β-cyclodextrin as aqueous monomer and dye rejection properties

Oxygen mass transfer performance of hollow fiber non-bubble aeration membrane based on gas/liquid-phase measurement method

Preparation process development of UiO-66-NH2@PVAm mixed matrix membranes for CO2 capture

Constructing nano-composite nanofiltration membranes by in-situ growth: membrane preparation and application

Poly(ethylene oxide)/crown ether blend membrane and performance for CO2 separation

Related Author

Lixue LIU

Shaofeng ZHANG

Changwei ZHAO

Erhu BAOLE

Ling YU

Jun WANG

YUAN Zhe

PAN Zhihui

Related Institution

School of Chemical Engineering, Hebei University of Technology

State Key Laboratory of Environment Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences

School of Civil Engineering and Transportation, Guangzhou University

Key Laboratory for Water Quality and Conservation of the Pearl River Delta, Ministry of Education

Zhejiang Kai Chuang Environment Technology Co., Ltd.

⁰