Surface temperature distribution of droplet heated by local microheater

胡定华

您当前的位置：

首页 >

文章列表页 >

Surface temperature distribution of droplet heated by local microheater

更新时间：2025-12-10

- Surface temperature distribution of droplet heated by local microheater
- CIESC Journal Issue 11, (2011)
- 作者机构：
  
  上海交通大学机械与动力工程学院
- 作者简介：
- 基金信息：
- DOI：
  CLC： 0.3969/j.issn.0438-1157.2011.11.009
- Online First：05 November 2011，
  
  Published：05 November 2011
- 稿件说明：
移动端阅览
胡定华. Surface temperature distribution of droplet heated by local microheater[J]. CIESC Journal, 2011, (11).
DOI：

胡定华. Surface temperature distribution of droplet heated by local microheater[J]. CIESC Journal, 2011, (11). DOI：

摘要

液滴表面温度分布直接影响液滴内部微流状况，而目前文献对液滴表面温度研究主要基于平板全局加热模式。采用MEMS集成工艺和红外热像分析手段，对基于中心局部微型加热下的液滴表面温度分布特性进行了实验研究。研究发现：局部加热液滴表面温度分布与平板全局加热液滴表面温度分布不同，呈现顶端温度高、边缘温度低的凸形温度分布规律；随着加热功率增加，液滴表面温度和温度梯度都会随之增加，而当加热功率增加到一定值后，液滴表面温度增幅趋于一致，表面温度梯度趋于稳定分布状态。同时对液滴局部沸腾时气泡破裂前后液滴表面温度分布进行了研究。研究结果有助于理解和控制液滴微流分布。

Abstract

The temperature distribution of droplet surface directly influences the microflow inside the droplet

but most of the papers about droplet surface temperature are based on substrate heating mode. In this study

with the aid of the infrared thermograph and MEMS technology

both the surface temperature and the temperature gradient of the droplet were investigated based on local heating mode. It was found that different from the concave distribution of surface temperature in the substrate heating mode

the surface temperature of the droplet in the local heating mode showed a convex distribution with a higher temperature at the apex but a lower temperature at the edge. With the increase of heating power

both the surface temperature and the temperature gradient were increased. However

as the heating power reached a certain value

the surface temperature gradient increased less and finally tended to a uniform distribution. The surface temperature of the droplet before and after the bubble burst under local boiling was also investigated. The results presented in this paper help to understand the internal microflow of droplets in the local heating mode and manipulate the microflow inside droplets.

关键词

Keywords

references

Views

669

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Mechanism and regulation of supercooling behavior in imidazolium-based ionic liquids

Heat transfer mechanisms, bottleneck identification and optimization in heat exchanger networks under variable operating conditions

Identification of gas-liquid two-phase flow patterns in a riser based on recursive characteristics and CNN

Performance of alkali metal-loaded SrMnO3 oxygen carriers in chemical looping oxidative dehydrogenation of ethylbenzene

Thermo-oxidative degradation characteristics of TPT backsheet from end-of-life photovoltaic modules

Related Author

No data

Related Institution

No data

⁰