石灰石和白云石高温循环脱除CO<sub>2</sub>过程分析

李英杰; 孙荣岳; 刘红玲; 赵建立; 韩奎华; 路春美

您当前的位置：

首页 >

文章列表页 >

石灰石和白云石高温循环脱除CO₂过程分析

更新时间：2025-12-10

- 石灰石和白云石高温循环脱除CO₂过程分析
- CIESC Journal Issue 6, Pages: 1693-1700(2011)
- 作者机构：
  
  山东大学燃煤污染物减排国家工程实验室
- 作者简介：
- 基金信息：
- DOI：
  CLC：
- Online First：05 June 2011，
  
  Published：05 June 2011
- 稿件说明：
移动端阅览
李英杰, 孙荣岳, 刘红玲, et al. 石灰石和白云石高温循环脱除CO₂过程分析[J]. CIESC Journal, 2011, (6): 1693-1700.
DOI：

李英杰, 孙荣岳, 刘红玲, et al. 石灰石和白云石高温循环脱除CO₂过程分析[J]. CIESC Journal, 2011, (6): 1693-1700. DOI：

摘要

在N2气氛和高浓度CO2气氛两种典型煅烧气氛下，对石灰石和白云石在循环煅烧/碳酸化捕集CO2过程中的主要系统参数包括长周期循环碳酸化转化率、平均碳酸化转化率、CO2捕集效率和煅烧炉能量需求进行了实验研究和计算分析。结果表明，吸收剂补充流率和吸收剂循环流率对平均碳酸化转化率、CO2捕集效率和煅烧炉所需能量具有直接影响。在相同吸收剂补充流率和循环流率条件下，采用白云石时的平均碳酸化转化率、CO2捕集效率均高于采用石灰石时；在CO2捕集效率为95％和相同煅烧气氛时，采用白云石的煅烧炉所需最小能量至少比石灰石节省82 kJ·（mol CO2）-1。与N2气煅烧气氛相比，在高浓度CO2煅烧气氛下得到的吸收剂平均碳酸化转化率、CO2捕集效率均下降，煅烧炉所需最小能量增加，但采用白云石时主要系统参数的变化均小于石灰石。

Abstract

The main system parameters

including longterm cyclic carbonation conversion

average carbonation conversion

CO2 capture efficiency and energy requirement for a calciner in the two kinds of typical calcination atmospheres

including pure N2 and high concentration CO2 were investigated by experiment and calculation during the cyclic calcination/carbonation process for CO2 capture using limestone and dolomite.The results showed that fresh sorbent flow ratio and recycled sorbent flow ratio had direct effect on average carbonation conversion

CO2 capture efficiency and energy requirement for the calciner.For the same fresh sorbent and recycled sorbent flow ratios

dolomite exhibited greater average carbonation conversion and CO2 capture efficiency than limestone.At CO2 capture efficiency of 95％ and in the same calcination atmosphere

at least 82 kJ·（mol CO2）-1 was saved in the minimum energy requirement for the calciner using dolomite than that using limestone.Compared with the results in pure N2 calcination atmosphere

the two sorbents both showed a decrease in average carbonation conversion and CO2 capture efficiency for the sorbents and exhibited an increase in minimum energy requirement for the calciner in high concentration CO2 atmosphere

however

the changes of these main system parameters for dolomite were less than those for limestone.

关键词

Keywords

references

Views

428

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Absorption solubility calculation and process simulation for CO2 capture

Calcination/sulphation characteristics of limestone modified by acetic acid solution at O2/CO2 atmosphere

Experimental study on promotion of fine particles capture with wetting agents

Simulation for hydrogen production from sorption enhanced coke-oven gas steam reforming based on chemical looping combustion

Coupled processes of chemical reaction, heat and mass transfer in non-thermal equilibrium porous medium

Related Author

FEI Weiyang

GAO Guanghua

CHEN Jian

DONG Lihu

ZHENG Que

LI Qingzhao

ZHAO Changsui

WU Weifang

Related Institution

清华大学化学工程联合国家重点实验室

东南大学能源与环境学院

中国科学院工程热物理研究所

中国科学院研究生院

东北大学冶金物理化学所

⁰

石灰石和白云石高温循环脱除CO2过程分析

DOI：

摘要

Abstract

关键词

Keywords

references

石灰石和白云石高温循环脱除CO₂过程分析