MDC synthesis reaction catalyzed by ［HSO3-bpy］CF3SO3 ionic liquid

WANG Na; ZHAO Xinqiang; WU Xiuli; WANG Yanji

您当前的位置：

首页 >

文章列表页 >

MDC synthesis reaction catalyzed by ［HSO₃-bpy］CF₃SO₃ ionic liquid

更新时间：2025-12-10

- MDC synthesis reaction catalyzed by ［HSO₃-bpy］CF₃SO₃ ionic liquid
- CIESC Journal Issue 4, Pages: 887-891(2008)
- 作者机构：
  
  河北工业大学绿色化工与高效节能河北省重点实验室,天津,300130
- 作者简介：
- 基金信息：
- DOI：
  CLC：
- Online First：05 April 2008，
  
  Published：05 April 2008
- 稿件说明：
移动端阅览
WANG Na, ZHAO Xinqiang, WU Xiuli, et al. MDC synthesis reaction catalyzed by ［HSO₃-bpy］CF₃SO₃ ionic liquid[J]. CIESC Journal, 2008, (4): 887-891.
DOI：

WANG Na, ZHAO Xinqiang, WU Xiuli, et al. MDC synthesis reaction catalyzed by ［HSO₃-bpy］CF₃SO₃ ionic liquid[J]. CIESC Journal, 2008, (4): 887-891. DOI：

摘要

制备了一系列磺酸吡啶功能化酸性离子液体(ILs)，采用Hammett指示剂与紫外联用法测定了其酸强度。考察了各酸性离子液体在苯氨基甲酸甲酯(MPC)与甲醛缩合制备二苯甲烷二氨基甲酸甲酯(MDC)反应中的催化活性。结果表明，离子液体的酸强度与其催化活性关联较好;［HSO3-bpy］CF3SO3酸强度最高，催化活性也最好。以［HSO3-bpy］CF3SO3为催化剂兼溶剂，优化了MDC合成反应条件。在反应温度70℃，反应时间60 min，MPC与甲醛的摩尔比为12，离子液体与MPC的质量比为4的条件下，MDC产率最高可达91.5％。用水处理反应液，通过减压蒸馏后的离子液体可以循环使用5次以上。

Abstract

A series of sulfonic acid-functional ionic liquids (ILs) were prepared and their acid strength was determined by the Hammett method combined with UV-visible spectroscopy.Then the catalytic activity of the ILs for the synthesis of methylene diphenyl dimethylcarbamate (MDC) from methyl phenyl carbamate (MPC) and formaldehyde (HCHO) was evaluated.The result showed that the acid strength of the ILs was well consistent with their catalytic activity.The acidity of ［HSO3-bpy］CF3SO3 was the strongest and its catalytic activity was the highest.The reaction conditions for the synthesis of MDC were optimized using ［HSO3-bpy］CF3SO3 as reaction media.Under the suitable reaction conditions of 70℃

60 min

molar ratio of MPC to HCHO 12 and mass ratio of ILs to MPC 4

the yield of MDC was 91.5％.［HSO3-bpy］CF3SO3 could be reused more than five times after the removal of water by vacuum distillation.

关键词

Keywords

references

Views

532

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Extraction of extracellular polymeric substances from activated sludge in membrane bioreactor

Mechanism and regulation of supercooling behavior in imidazolium-based ionic liquids

Study on the residence time distribution characteristics of the TPMS-Diamond static mixer

New universal corresponding state equation for correlation and extrapolation of saturated vapor-liquid density

Study on synergistic modification of nitrogen-doped carbon coating and Ti⁴⁺ co-doping for lithium vanadium phosphate cathode materials

Related Author

ZHANG Hongwei

LEI Ming

LI Ying

ZHANG Xuehua

WANG Jie

Related Institution

天津大学环境科学与工程学院

⁰