SO<sub>2</sub> emission characteristics of circulating fluidized bed boiler co-firing coal and petroleum coke

DUAN Lunbo; CHEN Xiaoping; LIANG Cai; LI Yingjie; LI Qingzhao; ZHAO Changsui

您当前的位置：

首页 >

文章列表页 >

SO₂ emission characteristics of circulating fluidized bed boiler co-firing coal and petroleum coke

更新时间：2025-12-10

- SO₂ emission characteristics of circulating fluidized bed boiler co-firing coal and petroleum coke
- CIESC Journal Issue 3, Pages: 728-734(2008)
- 作者机构：
  
  东南大学洁净煤发电及燃烧技术教育部重点实验室
- 作者简介：
- 基金信息：
- DOI：
  CLC：
- Online First：05 March 2008，
  
  Published：05 March 2008
- 稿件说明：
移动端阅览
DUAN Lunbo, CHEN Xiaoping, LIANG Cai, et al. SO₂ emission characteristics of circulating fluidized bed boiler co-firing coal and petroleum coke[J]. CIESC Journal, 2008, (3): 728-734.
DOI：

DUAN Lunbo, CHEN Xiaoping, LIANG Cai, et al. SO₂ emission characteristics of circulating fluidized bed boiler co-firing coal and petroleum coke[J]. CIESC Journal, 2008, (3): 728-734. DOI：

摘要

在工业运行的410 t·h-1循环流化床锅炉上进行烟煤、70％烟煤＋30％石油焦和50％无烟煤＋50％石油焦的燃烧试验，研究了运行参数对SO2排放特性的影响。结果表明，3种燃料均能达到良好的燃烧效果，炉内温度场分布均匀。在相同燃烧条件下，不同燃料SO2排放量与其中的含硫量呈正相关关系。SO2排放量随温度的升高先减小后增大，存在最佳脱硫温度；随钙硫比的增大而减小；随过量空气系数的增大而减小；随飞灰再循环量的增大而减小。对于不同种类的石灰石，大比表面积和高比孔容积的石灰石对SO2有较好的脱除效果。考察了燃用不同燃料的最佳温度、钙硫比和过量空气系数，阐述了飞灰再循环和石灰石微观结构在循环流化床锅炉脱硫中的机理和作用，以期对循环流化床的设计和运行工作提供指导。

Abstract

The combustion characteristics of a 410 t·h-1 circulating fluidized bed (CFB) boiler burning the fuels of bituminous coal (BC)

70% BC+30% petroleum coke (PC) and 50% anthracite (AN) +50% PC were studied. The effects of operation parameters

including bed temperature

molar ratio of Ca to S

excess air coefficient

fly ash recirculation rate and limestone microstructure on SO2 emission were investigated. Test results indicated that all the three kinds of fuels burned adequately in the boiler

and the bed temperature distribution was uniform. For different fuels

SO2 emission was correspondingly related to fuel sulfur content with the same operation parameters. With increasing bed temperature

SO2 concentration in the flue gas reduced first and then increased. There was an optimal desulfurization temperature. For burning BC only or 70% BC +30% PC

the optimal desulfurization temperature was about 850℃

while it was between 850－870℃ for burning 50% AN +50% PC

because of the different sulfur contents in the fuel. The SO2 concentration decreased with increasing Ca/S ratio

excess air coefficient and fly ash recirculation rate. The results also showed that the microstructures of limestones including specific surface area and specific pore volume had distinct impact on their SO2 retention. Larger specific surface area and higher specific pore volume could enhance their SO2 capture activities to a certain extent. The optimal temperatures

Ca/S ratios and excess air coefficients for different fuels were recommended for industrial application.

关键词

Keywords

references

Views

303

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Study on chemical kinetics of Na2SO4 formation in coal fired flue gas

Effect of SO2 on CO2 sorption characteristics using solid amine CO2 sorbent

Characteristics of NOx and SO2 emission from combustion of antibiotic mycelial residue with high water content in fluidized bed reactor

Crystal structure and leaching performance of MgO-containing calcium aluminate clinkers doped with Na2SO4

Simultaneous control of PM2.5 and SO3 by chemical agglomeration collaborative electrostatic precipitation

Related Author

ZHANG Zhichao

LIU Jing

YANG Yingju

ZHANG Zhen

ZHANG Wenjing

WU Ye

CAI Tianyi

LIU Daoyin

Related Institution

State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology

Key Laboratory of Energy Thermal Conversion and Control of Ministry of Education, Southeast University

MIIT Key Laboratory of Thermal Control of Electronic Equipment, Nanjing University of Science and Technology

State Key Laboratory of Multi-phase Complex Systems, Institute of Process Engineering, Chinese Academy of Sciences

School of Chemistry and Chemical Engineering, University of Chinese Academy of Sciences

⁰

SO2 emission characteristics of circulating fluidized bed boiler co-firing coal and petroleum coke

DOI：

摘要

Abstract

关键词

Keywords

references

SO₂ emission characteristics of circulating fluidized bed boiler co-firing coal and petroleum coke