DEACTIVATION MECHANISM OF DIETHYL OXALATE SYNTHESIS BY VAPOR PHASE CATALYTIC COUPLING REACTION OF CO AFTER INTRODUCTION OF HYDROGEN

LI Zhenhua; XU Genhui; WANG Baowei; MA Xinbin; DU Pa

您当前的位置：

首页 >

文章列表页 >

DEACTIVATION MECHANISM OF DIETHYL OXALATE SYNTHESIS BY VAPOR PHASE CATALYTIC COUPLING REACTION OF CO AFTER INTRODUCTION OF HYDROGEN

更新时间：2025-12-10

- DEACTIVATION MECHANISM OF DIETHYL OXALATE SYNTHESIS BY VAPOR PHASE CATALYTIC COUPLING REACTION OF CO AFTER INTRODUCTION OF HYDROGEN
- CIESC Journal Issue 1, Pages: 59-63(2003)
- 作者机构：
  
  天津大学化工学院一碳化学与化工国家重点实验室
- 作者简介：
- 基金信息：
- DOI：
  CLC：
- Online First：25 January 2003，
  
  Published：25 January 2003
- 稿件说明：
移动端阅览
LI Zhenhua, XU Genhui, WANG Baowei, et al. DEACTIVATION MECHANISM OF DIETHYL OXALATE SYNTHESIS BY VAPOR PHASE CATALYTIC COUPLING REACTION OF CO AFTER INTRODUCTION OF HYDROGEN[J]. CIESC Journal, 2003, (1): 59-63.
DOI：

LI Zhenhua, XU Genhui, WANG Baowei, et al. DEACTIVATION MECHANISM OF DIETHYL OXALATE SYNTHESIS BY VAPOR PHASE CATALYTIC COUPLING REACTION OF CO AFTER INTRODUCTION OF HYDROGEN[J]. CIESC Journal, 2003, (1): 59-63. DOI：

摘要

重点研究了氢气（H2）对一氧化碳（CO）催化偶联反应制草酸二乙酯的影响，分别考察了不同H2浓度、不同温度和不同空时条件下加入H2对CO偶联反应的影响，结果发现H2的加入使反应过程中CO转化率、草酸二乙酯选择性和空时收率明显下降，且在实验条件范围内，通入H2浓度越高、反应温度越高，催化剂活性下降越快.研究得出，H2气氛下CO偶联反应失活动力学方程为：-da/dt=kdc0.65H2.进一步分析失活动力学方程可知，加氢反应过程中，H2和CO吸附在同一个活性中心上，H2在活性中心上的吸附抑制了CO在催化剂上的吸附，从而使得CO催化偶联反应生成草酸二乙酯的速率下降，导致加氢后CO转化率、草酸二乙酯选择性和空时收率降低.

Abstract

In this paper

the effects of hydrogen on CO coupling reaction to diethyl oxalate at different hydrogen concentrations

reaction temperatures and residence times are studied. The results show that after introduction of hydrogen

CO conversion

selectivity and STY of diethyl oxalate all decrease with the increase of hydrogen concentration and reaction temperature. The deactivation kinetics of CO coupling reaction after introduction of hydrogen is obtained as follows:-da/dt=kdc0.65H2. According to this kinetic model the deactivation mechanism of the catalyst is further discussed. It is found that the co-adsorption of hydrogen and CO on the same active site of the catalyst occurrs.Adsorption of hydrogen will decrease the adsorption of CO on the catalyst and then decrease the formation rate of diethyl oxalate

CO conversion and space yield of diethyl oxalate.

关键词

Keywords

references

Views

618

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Hydrogen production from reform of bio-oil aqueous phase over Z204 catalyst using two-stage fixed bed reactor

Bimodal polyethylene produced by oscillating operation of hydrogen in single gas-phase polymerization reactor

Gasification of biomass model compounds in supercritical water

Quantum chemistry calculation of interaction of hydrogenand carbon nanotube defects

CATALYTIC COMBUSTION OF HYDROGEN/AIR IN MICROCHANNEL REACTOR

Related Author

WANG Tiejun

CHANG Jie

XU Ying

ZHANG Qi

WANG Lu

YANG Yongrong

WANG Jingdai

HUANG Xingbing

Related Institution

中国科学院广州能源研究所

中国科学院可再生能源与天然气水合物重点实验室

中国科学院研究生院

华南理工大学化工与能源学院

浙江大学化学工程与生物工程学系

⁰