Recycling treatment of membrane backwash water from sedimentation-ultrafiltration process

WANG Haiyan; ZHANG Weilin; HE Fenghua; GU Ping

您当前的位置：

首页 >

文章列表页 >

Recycling treatment of membrane backwash water from sedimentation-ultrafiltration process

更新时间：2025-12-10

- Recycling treatment of membrane backwash water from sedimentation-ultrafiltration process
- CIESC Journal Issue 2, Pages: 469-476(2011)
- 作者机构：
  
  1. 天津大学环境科学与工程学院
  2. 天津泰达自来水公司
- 作者简介：
- 基金信息：
- DOI：
  CLC：
- Online First：05 February 2011，
  
  Published：05 February 2011
- 稿件说明：
移动端阅览
WANG Haiyan, ZHANG Weilin, HE Fenghua, et al. Recycling treatment of membrane backwash water from sedimentation-ultrafiltration process[J]. CIESC Journal, 2011, (2): 469-476.
DOI：

WANG Haiyan, ZHANG Weilin, HE Fenghua, et al. Recycling treatment of membrane backwash water from sedimentation-ultrafiltration process[J]. CIESC Journal, 2011, (2): 469-476. DOI：

摘要

在处理以地表水为水源的沉淀池出水时，超滤技术存在产水率较低的问题，反洗水的回收可以有效地提高系统的产水率和降低运行成本。试验设计了两套小试微滤膜系统，将膜反洗水经过预处理后按1∶9比例与滦河水混合作为一套小试膜系统进水，另外一套小试膜系统处理滦河水。试验考察了两种预处理方式对于混配水膜系统的出水水质及膜污染的影响。结果表明，在膜反洗水中投加混凝剂和粉末活性炭（PAC）后，相对仅投加混凝剂的预处理方式，混配水系统的出水水质得到改善，UV254和CODMn的去除率分别提高了9%和6.3%，预处理方式对于混配水系统出水浊度没有影响，比通量衰减速率降低了16.6%。在反洗水经混凝和PAC吸附后，混配水和滦河水系统出水水质与膜污染状况未见显著差异。

Abstract

A low recovery rate was observed in the treatment of finished water from sedimentation tank with a UF membrane system

and recovery of membrane backwash water can improve productivity and reduce the cost of membrane treatment systems.In this study

two bench-scale coagulation microfiltration membrane systems were installed.The raw water of one membrane system was a blend of water from the pre-treated membrane backwash water and Luan River water in a 1∶9 ratio.Another membrane system was used to treat Luan River water.The aim of this study was to investigate effect of various pre-treatments on the finished water quality and membrane fouling rate.The results showed that the produced water quality from the mixed water system was improved with the addition of PAC in the pre-treatment of membrane backwash water

which was compared to the results obtained by coagulation.The removal rates of UV254 and CODMn were increased by 9% and 6.3%

respectively.There was no difference in turbidity of the produced waters by the various pre-treatments.Moreover

attenuation rate of SF was reduced by 16.6% with adding PAC in the pre-treatment.And the produced water quality from Luan River water system and membrane fouling rate were similar to those in mixed water system when the PAC was added in the pre-treatment.

关键词

Keywords

references

Views

334

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Microfiltration of fine TiO2 suspension with ultrasound-enhanced multi-channel ceramic membrane

Oxidation and coagulation of humic substances from landfill leachate by Fenton,s reagent

Preparation of poly-ferric aluminium silica sulfate coagulant from industrial wastes

Research progress of flux prediction models of micro-filtration membrane

Multi objective optimization of flow and heat transfer characteristics of modified manifold microchannel heat sink based on machine learning

Related Author

WANG Fenglai

CHEN Yazhong

CUI Peng

XIONG Wei

WU Yanyu

ZHOU Shaoqi

QIN Fanghui

LAI Yanglan

Related Institution

合肥工业大学化工学院，安徽省可控化学与材料化工重点实验室

华南理工大学环境科学与工程学院

宜宾学院化学化工系

四川理工学院化学系

北京工业大学环境与能源工程学院应用化学研究所

⁰