Preparation and characterization of desulfurizer loaded on attapulgite

ZHANG Zhihong; ZHANG Shaoyu; LIU Xuedong; LI Fengsheng

您当前的位置：

首页 >

文章列表页 >

Preparation and characterization of desulfurizer loaded on attapulgite

更新时间：2025-12-10

- Preparation and characterization of desulfurizer loaded on attapulgite
- CIESC Journal Issue 5, Pages: 1319-1324(2010)
- 作者机构：
  
  1. 南京理工大学国家特种超细粉体工程技术研究中心
  2. 江苏工业学院化学化工学院
  3. 江苏工业学院机械与能源工程学院
- 作者简介：
- 基金信息：
- DOI：
  CLC：
- Online First：05 May 2010，
  
  Published：05 May 2010
- 稿件说明：
移动端阅览
ZHANG Zhihong, ZHANG Shaoyu, LIU Xuedong, et al. Preparation and characterization of desulfurizer loaded on attapulgite[J]. CIESC Journal, 2010, (5): 1319-1324.
DOI：

ZHANG Zhihong, ZHANG Shaoyu, LIU Xuedong, et al. Preparation and characterization of desulfurizer loaded on attapulgite[J]. CIESC Journal, 2010, (5): 1319-1324. DOI：

摘要

采用沉淀法在凹凸棒石表面分别负载了铁和锌元素，制得Fe/凹凸棒石脱硫剂和Zn/凹凸棒石脱硫剂。用XRD、TEM和TPR等方法表征制得的两种凹凸棒石基脱硫剂，研究凹凸棒石基脱硫剂在氨水、盐酸中的稳定性;通过检测脱硫过程中尾气中H2S浓度的变化并分析脱硫剂的硫容比较两种脱硫剂的脱硫性能。分析了粒度、负载量和自体再生次数对铁脱硫剂的硫容的影响。结果表明，活性组分在凹凸棒石表面负载均匀;铁脱硫剂的脱硫性能较好，其硫容是活性炭的120倍，是锌脱硫剂的7.67倍;减小粒度和增加负载量都可以提高硫容，其自体有再生能力但再生仅能恢复脱硫剂的部分脱硫功能。Fe/凹凸棒石脱硫剂在脱硫领域有较好的应用前景。

Abstract

Fe/attapulgite and Zn/attapulgite desulfurizer were prepared by loading Fe and Zn element on attapulgite by precipitation.The desulfurizers were characterized by XRD，TEM and TPR.The stability of desulfurizers in ammonia water and hydrochloric acid was studied.Additionally，the changes of concentration of H2S in the off-gas were investigated in the sweetening process and the desulfurization capacities of two desulfurizers were compared.The influence of grain size，load amount and self-regeneration times on desulfurization capacity of Fe/attapulgite was studied.The results showed that active components were loaded on the surface of attapulgite uniformly.Fe/attapulgite had good desulfurization capability and self-reset capability，and its desulfurization capacity was 120 times that of active carbon and 7.67 times that of Zn/attapulgite.Decrease of grain size and increase of load amount could increase desulfurization capacity but regeneration by itself could only recover part of desulfurization capacity.Fe/attapulgite desulfurizer has wide application as a good desulfurizer.

关键词

Keywords

references

Views

221

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Behavior of zinc-based sorbents for simultaneous removal of H2S and COS from high-temperature coal gas and effect of Mo/Ni additives on desulfurization behavior

Construction of carbon nano-onions/ZnO composite cathode interfacial layers and their photovoltaic performance

ZnO-GA anode with gradient-pore distribution for lithium-ion battery

Preparation of C/ZnO composite based on camellia oleifera shell and its application in lead carbon battery

Electrochemical performance of Li3VO4 modified Ni-rich LiNi0.8Co0.1Mn0.1O2 cathode materials

Related Author

GAO Lianghao

ZHANG Xiaofen

DUAN Xinwei

MI Jie

WANG Jiancheng

WU Mengmeng

MU Fumao

MA Wenhao

Related Institution

State Key Laboratory of Clean and Efficient Coal Utilization, Taiyuan University of Technology

Key Laboratory of Coal Science and Technology, Ministry of Education, Taiyuan University of Technology

College of Environmental and Ecology, Taiyuan University of Technology

College of Materials Science and Engineering, Taiyuan University of Technology

Zheda Institute of Advanced Materials and Chemical Engineering

⁰