Atomization performance of low pressure swirl atomizing nozzle

YAN Yunfei; ZHANG Li; GAO Zhenyu; PU Ge

您当前的位置：

首页 >

文章列表页 >

Atomization performance of low pressure swirl atomizing nozzle

更新时间：2025-12-10

- Atomization performance of low pressure swirl atomizing nozzle
- CIESC Journal Issue 5, Pages: 1141-1147(2009)
- 作者机构：
  
  1. 重庆大学动力工程学院
  2. 重庆赛迪工业炉有限公司
- 作者简介：
- 基金信息：
- DOI：
  CLC：
- Online First：05 May 2009，
  
  Published：05 May 2009
- 稿件说明：
移动端阅览
YAN Yunfei, ZHANG Li, GAO Zhenyu, et al. Atomization performance of low pressure swirl atomizing nozzle[J]. CIESC Journal, 2009, (5): 1141-1147.
DOI：

YAN Yunfei, ZHANG Li, GAO Zhenyu, et al. Atomization performance of low pressure swirl atomizing nozzle[J]. CIESC Journal, 2009, (5): 1141-1147. DOI：

摘要

石灰浆液雾化喷嘴是烟气喷雾干燥脱硫系统的关键设备。利用Win212-2型激光粒度分析仪，对不同结构参数的低浓度石灰浆旋流雾化喷嘴的低压雾化性能进行了实验研究，得出了喷嘴结构参数对喷嘴雾化性能的影响规律和石灰浆低压旋流雾化喷嘴的最优化结构参数。优化后的喷嘴结构参数为：旋流片槽数为4，旋流片槽张角6°，旋流室收缩角90°，D/d=4.4～6.4

D/b=6～8

L/b=3.3～4.0。该喷嘴在0.8 MPa的低压下，雾化粒度可达到100 μm以下，雾化角为70°左右，具有良好的雾化性能，比普通喷嘴的雾化性能有较大提高。

Abstract

Lime slurry nozzle is the key equipment of flue gas drying desulfurization system.The nozzle atomization performance at different nozzle structural parameters was experimentally studied by using Win212-2 laser particle distribution analyzer.The influence of structural parameters on the lime slurry atomization and optimal nozzle structure were obtained.Under the atomizing pressure of 0.8 MPa

the nozzle showed good atomization performance in the condition of rotational channel numbers of 4

rotational channel expanding angle of 6°

rotational chamber shrinking angle of 90°

D/d=4.4—6.4

D/b=6—8 and L/b=3.3—4.0.The atomizing granularity and atomizing angle of the optimal nozzle were respectively less than 100 μm and about 70°.The atomization performance of optimal nozzle was greatly improved as compared with ordinary nozzle.

关键词

Keywords

references

Views

364

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Analysis of laminar heat transfer on super-hydrophobic surface with slip velocity

Influence of structural parameters on fluid flow and heat transfer in microchannel with periodically changeable cross-sections

Experimental invtestigation on performance of adjustable ejector

Methanol synthesis in an impinging stream reactor

Droplet size of two-fluid airblast atomizer with large water/air mass flux ratio

Related Author

LIU Tianqing

ZHOU Yuhong

FAN Xinxin

ZHOU Mingzheng

YANG Ruibo

CHAI Lei

XIA Guodong

LIU Jia

Related Institution

大连理工大学化工学院

北京工业大学环境与能源工程学院，强化传热与过程节能教育部重点实验室

大连理工大学海洋能源利用与节能教育部重点实验室

华东理工大学教育部煤气化重点实验室

华东理工大学资源与环境工程学院

⁰