Treatment of slightly polluted wastewater in a petroleum refinery by combined process of circulating biological aerated filter and filtration

XIE Wenyu; CHEN Jianjun; ZHONG Li; ZHONG Huawen

您当前的位置：

首页 >

文章列表页 >

Treatment of slightly polluted wastewater in a petroleum refinery by combined process of circulating biological aerated filter and filtration

更新时间：2025-12-10

- Treatment of slightly polluted wastewater in a petroleum refinery by combined process of circulating biological aerated filter and filtration
- CIESC Journal Issue 5, Pages: 1251-1256(2008)
- 作者机构：
  
  1. 茂名学院化工与环境工程学院
  2. 苏州大学化学化工学院
  3. 华南理工大学化学与化工学院
- 作者简介：
- 基金信息：
- DOI：
  CLC：
- Online First：05 May 2008，
  
  Published：05 May 2008
- 稿件说明：
移动端阅览
XIE Wenyu, CHEN Jianjun, ZHONG Li, et al. Treatment of slightly polluted wastewater in a petroleum refinery by combined process of circulating biological aerated filter and filtration[J]. CIESC Journal, 2008, (5): 1251-1256.
DOI：

XIE Wenyu, CHEN Jianjun, ZHONG Li, et al. Treatment of slightly polluted wastewater in a petroleum refinery by combined process of circulating biological aerated filter and filtration[J]. CIESC Journal, 2008, (5): 1251-1256. DOI：

摘要

采用新型的循环生物曝气滤池（CBAF）和过滤组合工艺对炼油轻度污染废水进行净化回用工业试验。研究了填料粒径和高度、水力停留时间和溶解氧浓度对CBAF工艺处理效果的影响。结果表明CBAF工艺具有碳化作用、硝化作用和过滤作用。CBAF工艺净化该废水适宜的操作条件为：水力停留时间100 min，溶解氧浓度3 mg·L-1左右，反冲洗周期2～3 d。炼油轻度污染废水经该组合工艺处理后，COD、石油类污染物、NH3-N和SS平均去除率分别为62.6%、71.7%、92.6%和97.0%，出水COD、石油类污染物、NH3-N和SS平均质量浓度分别为14.4 mg·L-1、0.75 mg·L-1、0.49 mg·L-1 和2.4 mg·L-1，经处理后出水水质达到工业回用水要求。

Abstract

A novel industrial-scale process combined circulating biological aerated filter (CBAF) and filtration was used to treat the slightly polluted wastewater for reuse in a petroleum refinery.The influences of packing size and height

hydraulic retention time and dissolved oxygen concentration on treatment efficiency for the CBAF process were investigated.The CBAF process can simultaneously carry out carbonation

nitrification and solids filtration in one unit.The wastewater was treated by the CBAF process under optimal conditions: hydraulic retention time of 100 min

dissolved oxygen concentration of about 3 mg·L-1 and the backwashing cycle of every 2—3 days.The results of the combined process showed that the average removal efficiency of COD

oil pollutants

NH3-N and SS was 62.6%

71.7%

92.6% and 97.0%

respectively.And the average effluent concentration of COD

oil pollutants

NH3-N and SS was 14.4 mg·L-1

0.75 mg·L-1

0.49 mg·L-1 and 2.4 mg·L-1

respectively.The quality of the effluent can meet the requirements of industrial water reuse.

关键词

Keywords

references

Views

168

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Influence of liquid properties on gas-liquid separation performance of filter

Microscale of flocs and separation characteristics in flocculation process of fermentation broth

Filtration and catalytic performance of blended TS-1/CNF composite catalyst

Optimal design of water utilization networks with multiple contaminants—water quality analysis and mathematical programming

Treatment of spent caustic wastewater from petroleum refinery using circulating biological aerated filter process

Related Author

JI Zhongli

LI Baisong

FENG Liang

ZHOU Guoquan

YANG Zehui

SHAO Qiongfang

WANG Jiarong

GAO Haoqi

Related Institution

中国石油大学机电工程学院

中国石油大学化学工程学院

宁波工程学院化工学院

化学工程联合国家重点实验室(华东理工大学)

河北工业大学化学工程与工艺系

⁰