Process and mechanism of indirect thermal drying of sewage sludge

WANG Xingrun; JIN Yiying; DU Xin; NIE Yongfeng

您当前的位置：

首页 >

文章列表页 >

Process and mechanism of indirect thermal drying of sewage sludge

更新时间：2025-12-10

- Process and mechanism of indirect thermal drying of sewage sludge
- CIESC Journal Issue 9, Pages: 2211-2215(2007)
- 作者机构：
  
  清华大学环境科学与工程系
- 作者简介：
- 基金信息：
- DOI：
  CLC：
- Online First：05 September 2007，
  
  Published：05 September 2007
- 稿件说明：
移动端阅览
WANG Xingrun, JIN Yiying, DU Xin, et al. Process and mechanism of indirect thermal drying of sewage sludge[J]. CIESC Journal, 2007, (9): 2211-2215.
DOI：

WANG Xingrun, JIN Yiying, DU Xin, et al. Process and mechanism of indirect thermal drying of sewage sludge[J]. CIESC Journal, 2007, (9): 2211-2215. DOI：

摘要

建立了序批式动态污泥间壁热干燥实验平台，并借此研究了干燥温度对干燥效率、干污泥热值、干污泥有机物含量（VS）、干燥冷凝水有机物含量（TOC）的影响;研究了水分蒸发速率与含水率的关系。结果表明：干燥温度低于160℃，水分蒸发速率较慢，干燥效率较低;干燥温度高于180℃，污泥絮体和微生物细胞发生破坏，水分存在形态发生改变，干燥效率提高较大，干污泥热值降低以及干燥冷凝水TOC浓度增加。干燥冷凝水属高浓度有机废水，须处理达标后才能排放。

Abstract

Using an improved rotary indirect agitated drying laboratory rig operating with recirculation gas in a closed system

this study investigated the influence of drying temperature on drying efficiency

calorific heating value and volatile solid content(VS) of the dry solid and total organic carbon (TOC) content of the condensate.In the meantime

the relationship between water evaporation rate and water content was also investigated.Experimental results indicated that when the drying temperature was under 160℃

water evaporation rate was very low and about two hours were needed for water content decreasing from 80% to 60%.However

the water evaporation rate increased significantly when the temperature reached 180℃ because hydrolysis and cytolysis of microorganism cells in sewage sludge occurred and the form of water existence was changed.The calorific heating value of dried solid decreased and the TOC of the condensate increased as a result.The condensate belonged to highly concentrated organic wastewater and must be treated before discharging to meet the effluent COD standard.

关键词

Keywords

references

Views

247

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Formations of solid and gas phase products during rapid pyrolysis of coal

Simulation of heat pipe biomass gasifier

Physics-informed spatio-temporal graph convolutional network for fermentation processes

Mixed matrix membranes based on nitrogen-rich Schiff base network polymer and their CO2 separation performance

Corrosion health status assessment method for refining unit pipeline based on GLAE-MLP

Related Author

YUAN Shuai

CHEN Xueli

LI Jun

DAI Zhenghua

ZHOU Zhijie

WANG Fuchen

王中贤

张红

Related Institution

华东理工大学煤气化教育部重点实验室

南京工业大学能源学院

⁰