EXPERIMENT ON HUMIDIFIER OF DETACHMENT-INTEGRATION STACK

WANG Cheng; MAO Zongqiang; XU Jingming; XIE Xiaofeng

您当前的位置：

首页 >

文章列表页 >

EXPERIMENT ON HUMIDIFIER OF DETACHMENT-INTEGRATION STACK

更新时间：2025-12-10

- EXPERIMENT ON HUMIDIFIER OF DETACHMENT-INTEGRATION STACK
- CIESC Journal Issue 11, Pages: 1608-1613(2003)
- 作者机构：
  
  清华大学核能技术设计研究院,北京,100084
- 作者简介：
- 基金信息：
- DOI：
  CLC：
- Online First：25 November 2003，
  
  Published：25 November 2003
- 稿件说明：
移动端阅览
WANG Cheng, MAO Zongqiang, XU Jingming, et al. EXPERIMENT ON HUMIDIFIER OF DETACHMENT-INTEGRATION STACK[J]. CIESC Journal, 2003, (11): 1608-1613.
DOI：

WANG Cheng, MAO Zongqiang, XU Jingming, et al. EXPERIMENT ON HUMIDIFIER OF DETACHMENT-INTEGRATION STACK[J]. CIESC Journal, 2003, (11): 1608-1613. DOI：

摘要

在已开发的分体式质子交换膜燃料电池电堆基础上，对膜（Nafion115）加湿器子系统进行了详细的研究，揭示了质子交换膜燃料电池膜加湿方法的特性.初步分析了膜加湿的原理，并在不同操作条件下，定量地对膜透过水量与反应气体的润湿程度进行了测量，得到了Nafion115膜加湿器对电堆的润湿性能.发现操作温度在50～70℃之间，加湿速率最强；随着反应气体流量的增大，加湿速率呈非线性增加，但润湿程度反而降低；增加质子交换膜面积会增大反应气体的相对湿度，而加湿速率将下降；较高反应气体压力下不利于加湿.在适当的膜加湿器工况下，当电流密度为2.1A8226;cm-2时，电堆最大功率密度可超过1.2W8226;cm-2.

Abstract

High-powered proton exchange membrane fuel cell(PEMFCs) can be used on electrical vehicles.The detachment-integration stack with active area of 390cm2 was developed. Based on it

research was concentrated on the subsystem of a Nafion115 membrane humidifier

and performance for membrane humidification. In this paper

the principle of membrane humidification is analyzed

and the effects of humidifying temperature

reaction gas pressure

reaction gas flow rate and power of hot water pump on humidification function are studied systematically. The results show that humidifying rate is fast between 50℃ and 70℃

and increases nonlinearly with gas flow.When the active area of membrane is enlarged

the humidifying rate will decrease

but the relative humidity of gas will increase.Humidification becomes more difficult at a higher gas pressure. Finally

the suitable operation conditions are determined.The maximum of the stack is more than 1.2W8226;cm-2 at the current density 2.1A8226;cm-2.

关键词

Keywords

references

Views

152

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

空气自呼吸式直接甲醇燃料电池传输特性数值研究

A comprehensive two-dimensional computational modelof PEM fuel cell with liquid water flooding

Effects of humidifying level of cathode and anode gas on mass transfer in PEMFC

Performance of alkali metal-loaded SrMnO3 oxygen carriers in chemical looping oxidative dehydrogenation of ethylbenzene

Mechanism and regulation of supercooling behavior in imidazolium-based ionic liquids

Related Author

苗政

邹金强

何雅玲

刘增

ZHANG Ya

ZHU Chunling

HE Guangli

DING Xinwei

Related Institution

西安交通大学能源与动力工程学院，动力工程多相流国家重点实验室，热流科学与工程教育部重点实验室（筹）

南京航空航天大学人机与环境工程系

大连理工大学化工学院

青森工业综合研究所

⁰