CIESC Journal ›› 2016, Vol. 67 ›› Issue (5): 2041-2047.doi: 10.11949/j.issn.0438-1157.20151536

Previous Articles     Next Articles

Simultaneous removal of SO2 and NOx by combination of ozone oxidation and Na2S2O3 solution spray

YANG Ye, XU Chaoqun, ZHU Yanqun, LIN Fawei, MA Qiang, WANG Zhihua, CEN Kefa   

  1. State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, Zhejiang, China
  • Received:2015-10-12 Revised:2015-11-25 Online:2016-05-05 Published:2015-12-16
  • Supported by:

    supported by the National Basic Research Program of China (2012CB214906) and the National Science Fund for Distinguished Young Scholars of China (51422605).

PDF (PC)

549

Abstract:

Ozone oxidation and Na2S2O3 solution spray was combined to remove SO2 and NOx simultaneously. This coupling was studied experimentally. The results show that: SO2 and NOx can be eliminated simultaneously; at O3/NO mole ratio 1.1—1.2, the NOx removal efficiency increases with increasing concentration of Na2S2O3; existence of SO2 can facilitate removal of NOx; the NOx removal efficiency reaches 70% with low emission of SO2 at Na2S2O3 concentration 2.0% and at SO2 gas concentration 1030 mg·m-3. Furthermore, the NOx removal efficiency is enhanced with the pH of solution from 2.5 to 9, and reaches 75% at pH 9. The result of 3 hours running experiment indicates that NOx and SO2 can be removed efficiently and simultaneously and the stable and continuous operation is possible, because sodium thiosulfate can facilitate removal of NOx and the NOx is dominantly converted into NO2-. This process could be an efficient approach for eliminating SO2 and NOx simultaneously and could have potential industrial application.

Key words: ozone oxidation, pollution, flue gas, simultaneous removal of SO2 and NOx, sodium thiosulfate, absorption

CLC Number: 

  • X511

[1] 环境保护部, 中华人民共和国国家质量监督检疫总局. 火电厂大气污染物排放标准: GB 13223—2011 [S]. 北京: 中国环境科学出版社, 2011. Ministry of Environmental Protection, General Administration of Quality Supervision of the People's Republic of China. Emission standard of air pollutants for thermal power plants: GB 13223—2011[S]. Beijing: China Environmental Science Press, 2011.
[2] CHENG J, ZHOU J H, LIU J Z, et al. Sulfur removal at high temperature during coal combustion in furnaces: a review [J]. Progress in Energy and Combustion Science, 2003, 29 (5): 381-405. DOI: 10.1016/S0360-1285(03)00030-3.
[3] 陈国庆, 高继慧, 黄启龙, 等. 钙基脱硫工艺协同脱硝技术研究进展 [J]. 化工进展, 2015, 34 (10): 3755-3761. DOI: 10.16085/j.issn.1000-6613.2015.10.036. CHEN G Q, GAO J H, HUANG Q L, et al. Research progress of SO2 and NOx synergistic removal by calcium-based desulfurization [J]. Chemical Industry and Engineering Progress, 2015, 34 (10): 3755-3761. DOI: 10.16085/j.issn.1000-6613.2015.10.036.
[4] MAN C K, GIBBINS J R, WITKAMP J G, et al. Coal characterization for NOx prediction in air-staged combustion of pulverised coals [J]. Fuel, 2005, 84 (17): 2190-2195. DOI: 10.1016/j.fuel.2005.06.011.
[5] MONLINA A, EDDINGS E G, PERSHING D W, et al. Nitric oxide destruction during coal and char oxidation under pulverized-coal combustion conditions [J]. Conbustion and Flame, 2004, 136 (3): 303-312. DOI: 10.1016/j.combustflame.2003.10.009.
[6] CAI L G, SHANG X, GAO S Q, et al. Low-NOx coal combustion via combining decoupling combustion and gas reburning [J]. Fuel, 2013, 112:695-703. DOI: 10.1016/j.fuel.2011.12.028.
[7] WANG Z H, ZHOU J H, ZHU Y Q, et al. Simultaneous removal of NOx,SO2 and Hg in nitrogen flow in a narrow reactor by ozone injection: experimental results [J]. Fuel Process Technology, 2007, 88 (8):817-823. DOI: 10.1016/j.fuproc.2007.04.001.
[8] 张相, 朱燕群, 王智化, 等. 臭氧氧化多种污染物协同脱除及副产物提纯的试验研究 [J]. 工程热物理学报, 2012, 33 (7): 1259-1262. ZHANG X, ZHU Y Q, WANG Z H, et al. Experimental research for multi-pollution control by ozone and by-product purification [J]. Journal of Engineering Thermophysics, 2012, 33 (7): 1259-1262.
[9] SKALSKA K, MILLER J S, WILK M, et al. Nitrogen oxides ozonation as a method for NOx emission abatement [J]. Ozone: Science & Engineering, 2012, 34 (4): 252-258. DOI: 10.1080/01919512.2012.686869.
[10] SKALSKA K, MILLER J S, LEDAKOWICZ S. Kinetics of nitric oxide oxidation [J]. Chemical Papers, 2010, 64 (2): 269-272. DOI: 10.2478/s11696-009-0105-8.
[11] MOK Y S, LEE H J. Removal of sulfur dioxide and nitrogen oxides by using ozone injection and absorption-reduction technique [J]. Fuel Processing Technology, 2006, 87 (7): 591-597. DOI: 10.1016/j.fuproc.2005.10.007.
[12] STANMATE E, CHEN W, JORGENSEN L, et al. IR and UV gas absorption measurements during NOx reduction on an industrial natural gas fired power plant [J]. Fuel, 2010, 89 (5):978-985. DOI: 10.1016/j.fuel.2009.11.044.
[13] 王智化. 燃煤多种污染物一体化协同脱除机理及反应射流直接数值模拟DNS的研究 [D]. 杭州: 浙江大学, 2005. WANG Z H. Mechanism study on multi-pollution control simultaneously during coal combustion and direct numerical simulation of reaction jets flow[D]. Hangzhou: Zhejiang University, 2005.
[14] HIROTA K, KOJIMA T. Decomposition behavior of PCDD/F isomers in incinerator gases under electron-beam irradiation [J]. Bulletin of the Chemical Society of Japan, 2005, 78 (9): 1685-1690. DOI: 10.1246/bcsj.78.1685.
[15] WANG Q, YAN J H, TU X, et al. Thermal treatment of municipal solid waste incinerator fly ash using DC double arc argon plasma [J]. Fuel, 2009, 88 (5): 955-958. DOI: 10.1016/j.fuel.2008.12.011.
[16] CHIEN T W, CHU H. Removal of SO2 and NO from flue gas by wet scrubbing using an aqueous NaClO2 solution [J]. Journal of Hazardous Materials, 2000, 80 (1-3): 43-57. DOI: 10.1016/S0304-3894(00)00274-0.
[17] 张相. 臭氧结合钙基吸收多种污染物及副产物提纯的试验与机理研究 [D]. 杭州: 浙江大学, 2012. ZHANG X. Experimental and mechanism investigation on multi-pollutant absorption by ozone with calcium based scrubbing and by-product treatment [D]. Hangzhou: Zhejiang University, 2012.
[18] MOK Y S. Absorption-reduction technique assisted by ozone injection and sodium sulfide for NOx removal from exhaust gas [J]. Chemical Engineering Journal, 2006, 118 (1/2): 63-67. DOI: 10.1016/j.cej.2006.01.011.
[19] ZHANG J, ZHANG R, CHEN X, et al. Simultaneous removal of NO and SO2 from flue gas by ozone oxidation and NaOH absorption [J]. Industrial & Engineering Chemistry Research, 2014, 53 (15):6450-6456. DOI: 10.1021/ie403423p.
[20] 曹向禹, 崔崇威, 黄君礼. 硫代硫酸钠还原二氧化氯的动力学 [J]. 高校化学工程学报, 2007,21 (5): 803-807. CAO X Y, CUI C W, HUANG J L. Kinetics of chlorine dioxide reduction by thiosulfate [J]. Journal of Chemical Engineering of Chinese Universities, 2007, 21 (5): 803-807.
[21] 张明慧, 马强, 徐超群, 等. 臭氧氧化结合湿法喷淋对玻璃窑炉烟气同时脱硫脱硝实验研究 [J]. 燃料化学学报, 2015, 43 (1): 88-93. ZHANG M H, MA Q, XU C Q, et al. Simultaneous removal of NOx and SO2 from glass furnace flue gas by ozone oxidation and spray tower [J]. Journal of Fuel Chemistry and Technology, 2015, 43 (1): 88-93.
[22] 杜振. 湿式氨法烟气脱硫脱硝过程中NOx吸收的实验研究[D]. 杭州: 浙江大学, 2011. DU Z. Study of NOx absorption in ammonia-based wet flue gas desulfurization and denitrification process[D]. Hangzhou: Zhejiang University, 2011.
[23] 刘颖祖, 朱燕群, 马强, 等. 臭氧多脱副产物亚硝酸钙的复盐沉淀试验研究 [J]. 化工学报, 2014, 65 (12): 4965-4970. DOI: 10.3969/j.issn.0438-1157.2014.12.043. LIU Y Z, ZHU Y Q, MA Q, et al. Double-salt precipitation of Ca(NO2)2 derived from multi-pollution control process by ozone [J]. CIESC Journal, 2014, 65 (12): 4965-4970. DOI: 10.3969/j.issn.0438-1157.2014.12.043.
[24] 中华人民共和国卫生部, 中国国家标准化管理委员会. 臭氧发生器安全与卫生标准: GB 28232—2011 [S]. 北京: 中国标准出版社, 2011. Ministry of Health, Inspection and Quarantine of the People's Republic of China. Safety and sanitation standard for ozone generator: GB 28232—2011[S]. Beijing: Standards Press of China, 2011.
[1] SU Hui, ZHU Zhaowu, WANG Lina, QI Tao. Research progress in extraction and recovery of lithium from hard-rock ores [J]. CIESC Journal, 2019, 70(1): 10-23.
[2] PAN Peiyuan, CHEN Heng, JIAO Jian, LIANG Zhiyuan, ZHAO Qinxinq. In-plant experimental study on desulfurized flue gas corrosion [J]. CIESC Journal, 2019, 70(1): 161-169.
[3] WU Yuanmo, ZHANG Shouyu, ZHANG Hua, MU Chen, LI Hao, SONG Xiaobing, LYU Junfu. Relationship between pore structure and moisture reabsorption of lignite dewatered by high temperature drying process [J]. CIESC Journal, 2019, 70(1): 199-206.
[4] WANG Zizong, LIU Hongqian, WANG Jiming. Research and optimization of separation technology of methanol to propylene [J]. CIESC Journal, 2019, 70(1): 136-145.
[5] HOU Mengjie, ZHANG Xinru, WANG Yonghong, LI Jinping, LIU Chengcen, LING Jun. Preparation of PVAm mixed matrix membranes by incorporating halloysite nanotubes for CO2/N2 separation [J]. CIESC Journal, 2018, 69(9): 4106-4113.
[6] LI Yajuan, ZHAO Chuanqi, YANG Yuesuo, WANG Yuanyuan, SONG Xiaoming. Mechanism and model of dynamic adsorption of glyphosate contaminated water on graphene-based iron oxide composite [J]. CIESC Journal, 2018, 69(9): 3944-3953.
[7] LIU Dunyu, WALL Terry, STANGER Rohan. Experimental and modelling study on co-absorption of SO2 and CO2 during desulfurization process by flue gas cooler for oxy-fuel combustion flue gas [J]. CIESC Journal, 2018, 69(9): 4019-4029.
[8] HAN Tianyi, YAO Yuan, XU Jun, QI Liqiang, LI Jintao, TENG Fei. Synergetic mechanism of hygroscopic agent, surfactant and catalyst on desulfurization of flue gas circulating fluidized bed [J]. CIESC Journal, 2018, 69(9): 4044-4050.
[9] HU Xiaowei, LÜ Li, LIANG Bin, QIU Liyou, YUAN Shaojun, ZHENG Dongyao. Reaction and regeneration behavior of melamine with SO2 [J]. CIESC Journal, 2018, 69(9): 4012-4018.
[10] WEN Yujuan, YANG Yuesuo, SONG Xiaoming, ZHANG Xi, LI Huizhong. Characteristics of p-nitrophenol removal by SAT system with iron oxide coated sands [J]. CIESC Journal, 2018, 69(7): 3059-3067.
[11] SU Mingxu, MUHAMMAD Abdul Ahad, JIANG Yong, WU Wei, YANG Huinan. Synchronous thickness measurements of flowing liquid film on horizontal surface by ultrasonic pulse-echo and laser absorption spectroscopy methods [J]. CIESC Journal, 2018, 69(7): 2972-2978.
[12] ZHAO Ning, WANG Peipei, GUO Suna, FANG Lide, WANG Dongxing, CHEN Xue. Interfacial disturbance wave velocity of gas-liquid two-phase annular flow in vertical pipe [J]. CIESC Journal, 2018, 69(7): 2926-2934.
[13] JI Ruijun, XU Wenqing, WANG Jian, YAN Chaoyu, ZHU Tingyu. Research progress of ozone oxidation denitrification technology [J]. CIESC Journal, 2018, 69(6): 2353-2363.
[14] MENG Qingying, CAO Yu, HUANG Yanzhao, WANG Le, LI Li, NIU Shufeng, QI Hong. Effects of process parameters on water and waste heat recovery from flue gas using ceramic ultrafiltration membranes [J]. CIESC Journal, 2018, 69(6): 2519-2525.
[15] YIN Andong, DENG Wenyi, MA Jingchen, SU Yaxin. Properties on NO removal over pyrolyzed sludge carbon [J]. CIESC Journal, 2018, 69(6): 2655-2663.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
Copyright © 2019 CIESC Journal, All Rights Reserved.
Powered by Beijing Magtech Co. Ltd