Photo-thermal properties of MWCNT-H2O nanofluid

doi:10.11949/j.issn.0438-1157.20160797

Abstract

Abstract:

Stable aqueous suspensions of multi-walled carbon nanotubes (MWCNTs) with mass fractions ranging from 0.0015% to 0.1% were prepared via two-step method.The impacts of mass fraction, setting time, and heating times on the optical absorption property of MWCNT-H₂O nanofluid were investigated according to the transmittance measured by UV-VIS-NIR spectrophotometer over the wavelength from 200 to 2000 nm.Furthermore, an insolation experiment was performed to investigate the effects of mass fraction and light irradiation times on the photo-thermal property of MWCNT-H₂O nanofluids.Results show that the transmittance of MWCNT-H₂O nanofluid was decreased evidently after the addition of MWCNTs in deionized (DI) water, and long setting time leads to smaller transmittance.Heating is beneficial to improve light-absorption property of nanofluids.An optimal mass fraction of 0.01% with respect to the best photo-thermal conversion was found.Compared to DI water, the temperature of MWCNT-H₂O nanofluid at the optimal mass fraction was increased by about 15.1℃ (or 22.7%) after a lighting time of 45 min.Additionally, photo-thermal conversion performance is enhanced with increasing the lighting time at a low concentration of nanofluid, while it is just opposite at higher concentrations.The nanoparticle agglomeration may account for the above results.

Key words: nanomaterial, solar energy, photo-thermal property, transmittance, agglomeration

摘要：

通过两步法配制了浓度范围0.0015%~0.1%（质量，下同）的多壁碳纳米管（MWCNT）-水纳米流体，并利用分光光度计对不同浓度、静置时间和加热次数下纳米流体在波长200~2000 nm范围内的透射率进行了测试。同时，还对上述纳米流体开展了闷晒实验，研究了浓度和光照次数对纳米流体光热转换性能的影响。结果表明，水中添加MWCNT后透射率明显下降，纳米流体的透射率随着静置时间的增加而减小，加热有利于提高纳米流体的吸光性能；同时，闷晒实验发现存在利于光热转化的MWCNT-水纳米流体最佳浓度（0.01%），光照45 min后与水相比最佳浓度下的纳米流体温升提高了约15.1℃（或22.7%）。另外，纳米流体浓度较低时其光热转换性能随着光照次数的增加而提高，但浓度较高时则刚好相反，纳米颗粒团聚作用可能是造成上述结果的主要原因。

关键词: 纳米材料, 太阳能, 光热特性, 透射率, 团聚

CLC Number:

TK124

QU Jian, TIAN Min, WANG Qian, HAN Xinyue. Photo-thermal properties of MWCNT-H₂O nanofluid[J]. CIESC Journal, 2016, 67(S2): 113-119.

屈健, 田敏, 王谦, 韩新月. 碳纳米管-水纳米流体的光热转化特性[J]. 化工学报, 2016, 67(S2): 113-119.

References 28

[1]	CHOI S U S.Enhancing thermal conductivity of fluids with nanoparticles[J].ASME, 1995, 231: 99-105.
[2]	SAIDUR R, LEONG K Y, MOHAMMAD H A.A review on applications and challenges of nanofluids[J].Renewable and Sustainable Energy Reviews, 2011, 15(3): 1646-1668.
[3]	LOMASCOLO M, COLANGELO G, MILANESE M, et al. Review of heat transfer in nanofluids: conductive, convective and radiative experimental results[J].Renewable and Sustainable Energy Reviews, 2015, 43: 1182-1198.
[4]	OTANICAR T P, PHELAN P E, PRASHER R S, et al. Nanofluid-based direct absorption solar collector[J].Journal of Renewable and Sustainable Energy, 2010, 2(3): 033102.
[5]	TAYLOR R A, PHELAN P E, OTANICAR T P, et al. Nanofluid optical property characterization: towards efficient direct absorption solar collectors[J].Nanoscale Research Letters, 2011, 6(1): 1-11.
[6]	VERMA S K, TIWARI A K.Progress of nanofluid application in solar collectors: a review[J].Energy Conversion and Management, 2015, 100: 324-346.
[7]	毛凌波, 张仁元, 柯秀芳, 等.纳米流体太阳集热器的光热性能研究[J].太阳能学报, 2009, 30(12): 1647-1652. MAO L B, ZHANG R Y, KE X F, et al.Photo-thermal properties of nanofluid-based solar collector[J].Acta Energiae Solaris Sinica, 2009, 30(12): 1647-1652.
[8]	ZHANG H, CHEN H J, DU X, et al.Photothermal conversion characteristics of gold nanoparticle dispersions[J]. Solar Energy, 2014, 100: 141-147.
[9]	BANDARRA FILHO E P, MENDOZA O S H, et al. Experimental investigation of a silver nanoparticle-based direct absorption solar thermal system[J].Energy Conversion and Management, 2014, 84: 261-267.
[10]	CHEN M, HE Y, ZHU J, et al.An experimental investigation on sunlight absorption characteristics of silver nanofluids[J].Solar Energy, 2015, 115: 85-94.
[11]	HE Q, WANG S, ZENG S, et al.Experimental investigation on photothermal properties of nanofluids for direct absorption solar thermal energy systems[J].Energy Conversion and Management, 2013, 73: 150-157.
[12]	KARAMI M, AKHAVAN-BAHABADI M A, DELFANI S, et al.Experimental investigation of CuO nanofluid-based direct absorption solar collector for residential applications[J].Renewable and Sustainable Energy Reviews, 2015, 52: 793-801.
[13]	徐国英, 李凌志, 张小松,等.添加不同纳米颗粒的导热油直接吸收集热实验性能[J].化工学报, 2014, 65(S2):293-298. XU G Y, LI L Z, ZHANG X S, et al.Experimental performance of direct absorption collector using heat-transfer oil added with different nanoparticles[J].CIESC Journal, 2014, 65(S2): 293-298.
[14]	MERCATELLI L, SANI E, ZACCANTI G, et al. Absorption and scattering properties of carbon nanohorn-based nanofluids for direct sunlight absorbers[J].Nanoscale Research Letters, 2011, 6(1): 1-9.
[15]	LADJEVARDI S M, ASNAGHI A, IZADKHAST P S, et al. Applicability of graphite nanofluids in direct solar energy absorption[J].Solar Energy, 2013, 94: 327-334.
[16]	LEE S H, JANG S P.Efficiency of a volumetric receiver using aqueous suspensions of multi-walled carbon nanotubes for absorbing solar thermal energy[J].International Journal of Heat and Mass Transfer, 2015, 80: 58-71.
[17]	DELFANI S, KARAMI M, AKHAVAN-BEHABADI M A.Performance characteristics of a residential-type direct absorption solar collector using MWCNT nanofluid[J]. Renewable Energy, 2016, 87: 754-764.
[18]	KARAMI M, BAHABADI M A A, DELFANI S, et al.A new application of carbon nanotubes nanofluid as working fluid of low-temperature direct absorption solar collector[J]. Solar Energy Materials and Solar Cells, 2014, 121: 114-118.
[19]	HORDY N, RABILLOUD D, MEUNIER J L, et al.High temperature and long-term stability of carbon nanotube nanofluids for direct absorption solar thermal collectors[J]. Solar Energy, 2014, 105: 82-90.
[20]	HORDY N, ARISTIZABAL F, COULOMBE S.Volumetric optical heating of carbon nanotube nanofluids[J]. International Journal of Heat and Mass Transfer, 2015, 88: 133-137.
[21]	MENG Z, WU D, WANG L, et al.Carbon nanotube glycol nanofluids: photo-thermal properties, thermal conductivities and rheological behavior[J].Particuology, 2012, 10(5): 614-618.
[22]	何钦波, 汪双凤, 曾社铨, 等.直接吸收式太阳能集热纳米流体辐射特性实验研究[J].制冷学报, 2014, 35(1): 109-113. HE Q B, WANG S F, ZENG S Q, et al.Experimental investigation on radiation characteristic of nanofluids for direct absorption solar thermal energy systems[J]. Journal of Refrigeration, 2014, 35(1): 109-113.
[23]	DENG R, HE Y, QIN Y, et al.Measuring pure water absorption coefficient in the near-infrared spectrum (900-2500 nm)[J]. Journal of Remote Sensing, 2012, 16(1): 192-206.
[24]	MODEST M F.Radiative Heat Transfer[M].Academic Press, 2013.
[25]	GHARAGOZLOO P E, GOODSON K E.Aggregate fractal dimensions and thermal conduction in nanofluids[J]. Journal of Applied Physics, 2010, 108(7): 074309.
[26]	DU M, TANG G H.Optical property of nanofluids with particle agglomeration[J].Solar Energy, 2015, 122: 864-872.
[27]	JING D, HU Y, LIU M, et al.Preparation of highly dispersed nanofluid and CFD study of its utilization in a concentrating PV/T system[J].Solar Energy, 2015, 112: 30-40.
[28]	SONG D, HATAMI M, WANG Y, et al.Prediction of hydrodynamic and optical properties of TiO2/water suspension considering particle size distribution[J]. International Journal of Heat and Mass Transfer, 2016, 92: 864-876.

Photo-thermal properties of MWCNT-H₂O nanofluid

碳纳米管-水纳米流体的光热转化特性

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References 28

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	Zhanyu YE, He SHAN, Zhenyuan XU. Performance simulation of paper folding-like evaporator for solar evaporation systems [J]. CIESC Journal, 2023, 74(S1): 132-140.
[2]	Cong QI, Zi DING, Jie YU, Maoqing TANG, Lin LIANG. Study on solar thermoelectric power generation characteristics based on selective absorption nanofilm [J]. CIESC Journal, 2023, 74(9): 3921-3930.
[3]	Yuanchao LIU, Bin GUAN, Jianbin ZHONG, Yifan XU, Xuhao JIANG, Duan LI. Investigation of thermoelectric transport properties of single-layer XSe₂(X=Zr/Hf) [J]. CIESC Journal, 2023, 74(9): 3968-3978.
[4]	Yu FU, Xingchong LIU, Hanyu WANG, Haimin LI, Yafei NI, Wenjing ZOU, Yue LEI, Yongshan PENG. Research on F₃EACl modification layer for improving performance of perovskite solar cells [J]. CIESC Journal, 2023, 74(8): 3554-3563.
[5]	Jiaqi CHEN, Wanyu ZHAO, Ruichong YAO, Daolin HOU, Sheying DONG. Synthesis of pistachio shell-based carbon dots and their corrosion inhibition behavior on Q235 carbon steel [J]. CIESC Journal, 2023, 74(8): 3446-3456.
[6]	Meibo XING, Zhongtian ZHANG, Dongliang JING, Hongfa ZHANG. Enhanced phase change energy storage/release properties by combining porous materials and water-based carbon nanotube under magnetic regulation [J]. CIESC Journal, 2023, 74(7): 3093-3102.
[7]	Yajie YU, Jingru LI, Shufeng ZHOU, Qingbiao LI, Guowu ZHAN. Construction of nanomaterial and integrated catalyst based on biological template: a review [J]. CIESC Journal, 2023, 74(7): 2735-2752.
[8]	Jiali GE, Tuxiang GUAN, Xinmin QIU, Jian WU, Liming SHEN, Ningzhong BAO. Synthesis of FeF₃ nanoparticles covered by vertical porous carbon for high performance Li-ion battery cathode [J]. CIESC Journal, 2023, 74(7): 3058-3067.
[9]	Maolin DONG, Lidong CHEN, Liulian HUANG, Weibing WU, Hongqi DAI, Huiyang BIAN. Research progress in preparation of lignonanocellulose by acid hydrotropes and their functional applications [J]. CIESC Journal, 2023, 74(6): 2281-2295.
[10]	Qin YANG, Chuanjian QIN, Mingzi LI, Wenjing YANG, Weijie ZHAO, Hu LIU. Fabrication and properties of dual shape memory MXene based hydrogels for flexible sensor [J]. CIESC Journal, 2023, 74(6): 2699-2707.
[11]	Yuanchao LIU, Xuhao JIANG, Ke SHAO, Yifan XU, Jianbin ZHONG, Zhuan LI. Influence of geometrical dimensions and defects on the thermal transport properties of graphyne nanoribbons [J]. CIESC Journal, 2023, 74(6): 2708-2716.
[12]	Hao ZHANG, Huibin XU, Jian GAO, Dihong LIU, Zehua ZHOU. Geldart-D wet particle tilt-fall behavior and its reinforcement [J]. CIESC Journal, 2023, 74(4): 1519-1527.
[13]	Jinsheng REN, Kerun LIU, Zhiwei JIAO, Jiaxiang LIU, Yuan YU. Research on the mechanism of disaggregation of particle aggregates near the guide vanes of turbo air classifier [J]. CIESC Journal, 2023, 74(4): 1528-1538.
[14]	Hao ZHANG, Ziyue WANG, Yujie CHENG, Xiaohui HE, Hongbing JI. Progress in the mass production of single-atom catalysts [J]. CIESC Journal, 2023, 74(1): 276-289.
[15]	Jing ZHANG, Tao LIU, Wei ZHANG, Zhenyu CHU, Wanqin JIN. Preparation of a novel separation-sensing membrane and its dynamic monitoring of blood glucose [J]. CIESC Journal, 2023, 74(1): 459-468.