化工学报 ›› 2020, Vol. 71 ›› Issue (7): 3354-3361.doi: 10.11949/0438-1157.20191537

• 材料化学工程与纳米技术 • 上一篇    下一篇

活性氧化铝基质新型复合吸附剂的制备和储热性能

刘华1,2,3(),彭佳杰3,余凯1,2,倪毅1,2,王芳1,2,潘权稳3(),葛天舒3,王如竹3   

  1. 1.空调设备及系统运行节能国家重点实验室,广东 珠海 517907
    2.珠海格力电器股份有限公司,广东 珠海 517907
    3.上海交通大学机械与动力工程学院,上海 200240
  • 收稿日期:2019-12-18 修回日期:2020-03-07 出版日期:2020-07-05 发布日期:2020-04-29
  • 通讯作者: 潘权稳 E-mail:liuhua@cn.gree.com;sailote@sjtu.edu.cn
  • 作者简介:刘华(1977—),男,博士研究生,高级工程师,liuhua@cn.gree.com
  • 基金资助:
    空调设备及系统运行节能国家重点实验室开放基金项目(ACSKL2018KT1203);上海市青年科技英才扬帆计划项目(19YF1423100);上海交通大学“新进青年教师启动计划”项目

Preparation and thermal storage performance of novel composite sorbent with activated alumina matrix

Hua LIU1,2,3(),Jiajie PENG3,Kai YU1,2,Yi NI1,2,Fang WANG1,2,Quanwen PAN3(),Tianshu GE3,Ruzhu WANG3   

  1. 1.State Key Laboratory of Air-Conditioning Equipment and System Energy Conservation, Zhuhai 517907, Guangdong, China
    2.Gree Electric Appliances, Inc. of Zhuhai, Zhuhai 517907, Guangdong, China
    3.School of Mechanical Engineering, Shanghai Jiao Tong University, Shanghai 200240, China
  • Received:2019-12-18 Revised:2020-03-07 Online:2020-07-05 Published:2020-04-29
  • Contact: Quanwen PAN E-mail:liuhua@cn.gree.com;sailote@sjtu.edu.cn

摘要:

研制了一种以活性氧化铝为基质、CaCl2为吸湿盐的新型复合吸附剂,可用于以水为吸附质的热化学吸附储热系统,并对其内部结构、吸附性能和储热性能进行了研究。利用恒温恒湿箱确定出现溶液泄漏现象的最大含盐量,并对30℃和多种相对湿度工况下的动态和平衡吸附特性进行测量,研究了含盐量和相对湿度对吸附剂的吸附特性的影响,结果表明含盐量和相对湿度越大,复合吸附剂的吸水能力越强。利用全自动比表面积与孔隙度分析仪测量材料的比表面积和孔体积,利用同步热分析仪测试了复合吸附剂的储热密度,其中含盐量最高的复合吸附剂的储热密度最高,质量和体积储热密度分别达到0.51 kW·h/kg和610.2 kW·h/m3,具有良好的储热性能。

关键词: 吸附, 吸附剂, 制备, 储热, 活性氧化铝, 氯化钙

Abstract:

A new type of composite adsorbent based on activated alumina(AA) and CaCl2 as a hygroscopic salt was developed. It can be used in thermochemical adsorption heat storage systems with water as the adsorbent, and its internal structure, adsorption performance and heat storage performance were studied. Samples with different salt contents were fabricated to store low-temperature thermal heat by impregnation methods. Morphologies records, sorption kinetics and thermal energy storage performance of AA/CaCl2 composite sorbent were investigated. The maximum salt content of the solution leakage phenomenon was determined. Sorption kinetics and equilibrium sorption capacity under conditions of 30 oC and multi relative humidity were studied by utilizing constant temperature and humidity chamber. Influence of salt content and relative humidity on the sorption performance of AA/CaCl2 composite sorbent was studied. Results showed sorption capacity of AA/CaCl2 composite sorbent increased with increasing salt content and relative humidity. The specific surface area and pore volume were measured by automatic specific surface area and porosity analyzer. Energy storage density was measured by simultaneous thermal analyzer. The sample with highest salt content had the best energy storage performance with 0.51 kW·h/kg mass energy storage density and 610.2 kW·h/m3 volumetric energy storage density. As a consequence, AA/CaCl2 composite sorbent is promising sorbent in field of chemisorption thermal energy storage.

Key words: adsorption, sorbent, preparation, heat storage, activated alumina, calcium chloride

中图分类号: 

  • TK 02

图1

复合吸附剂制作流程示意图"

表1

AA和AA/ CaCl2复合吸附剂的含盐量和堆积密度"

SampleMass salt content/%Bulk density(kg/m3)
AA0908.0
AACa54.7923.8
AACa106.3951.6
AACa158.3980.9
AACa2010.61028.2
AACa2515.31123.5
AACa3017.91208.2

图2

活性氧化铝照片(a)AA(b)、AACa15(c)、AACa30(d)的TEM影像"

图3

AA/ CaCl2复合吸附剂的动态吸附特性曲线(30℃和60%RH)"

图4

复合吸附剂在30℃、不同相对湿度条件下的平衡吸附量"

图5

复合吸附剂在30℃和60%RH条件下多次吸附/解吸的平衡吸附量"

表2

不同含盐量复合吸附剂的孔比表面积和孔体积"

样品比表面积(m2/g)孔体积(cm3/g)
AA238.770.39
AACa15197.730.30
AACa30128.810.23

图6

复合吸附剂的STA测试结果"

图7

复合吸附剂的质量储热密度"

图8

复合吸附剂的体积储热密度[4] 张艳楠, 王如竹, 李廷贤. 蛭石/氯化钙复合吸附剂的吸附特性和储热性能[J]. 化工学报, 2018, 69(1): 363-370.[7] 重复了 1Cabeza L F, Sole A, Barreneche C. Review on sorption materials and technologies for heat pumps and thermal energy storage[J]. Renewable Energy, 2017, 110: 3-39.[22] 许嘉兴, 李廷贤, 王如竹. 氯化镁/沸石复合材料的吸附特性及储热性能[J]. 化工学报, 2016, 67: 348-355.[24] 闫霆, 王文欢, 王程遥. 化学储热技术的研究现状及进展[J]. 化工进展, 2018, 37(12): 4586-4595.[29] 陈金妹, 张健. ASAP2020比表面积及孔隙分析仪的应用[J]. 分析仪器, 2009, (3): 61-64."

1 Cabeza L F, Solé A, Barreneche C. Review on sorption materials and technologies for heat pumps and thermal energy storage[J]. Renewable Energy, 2017, 110: 3-39.
2 Aydin D, Casey S P, Riffat S. The latest advancements on thermochemical heat storage systems[J]. Renewable and Sustainable Energy Reviews, 2015, 41: 356-367.
3 吴韶飞, 闫霆, 蒯子函, 等. 高导热膨胀石墨/棕榈酸定形复合相变材料的制备及储热性能研究[J]. 化工学报, 2019, 70(9): 3551-3562.
Wu S F, Yan T, Kuai Z H, et al. Preparation and thermal energy storage properties of high heat conduction expanded graphite/palmitic acid form-stable phase change materials[J]. CIESC Journal, 2019, 70(9): 3551-3562.
[1] 武君媛, 霍伟智, 李志强, 曾嘉恒, 江燕斌. 电纺zein-SLS纤维膜的制备及其离子吸附性能研究[J]. 化工学报, 2020, 71(S1): 252-260.
[2] 王晨, 折晓会, 张小松. 含空气净化过程的液态空气储能热力学研究[J]. 化工学报, 2020, 71(S1): 23-30.
[3] 赵惠忠, 雷敏, 黄天厚, 刘涛, 张敏. 复合吸附剂MWCNT/MgCl2的水蒸气吸附性能[J]. 化工学报, 2020, 71(S1): 272-281.
[4] 吴文翔, 韩小渠, 周志杰, 王宇, 种道彤. 循环转轮空调系统变工况除湿特性[J]. 化工学报, 2020, 71(S1): 355-360.
[5] 刘博文, 邓帅, 李双俊, 赵力, 杜振宇, 陈丽锦. 变温吸附碳捕集系统能效性能实验研究[J]. 化工学报, 2020, 71(S1): 382-390.
[6] 孙巍, 左然. MMAl在NH2与H混合覆盖的AlN(0001)-Al表面的吸附与扩散研究[J]. 化工学报, 2020, 71(7): 3213-3219.
[7] 刘涛, 张书廷. Ba、Co共掺MnOx复合氧化物低温选择性催化还原NO研究[J]. 化工学报, 2020, 71(7): 3106-3113.
[8] 胡京宇, 姚戎, 潘玉航, 朱超, 宋爽, 沈意. 可光助再生二氧化钛/层状双氢氧化物去除水体中有机染料[J]. 化工学报, 2020, 71(7): 3296-3303.
[9] 刘昌会,黄文博,顾彦龙,饶中浩. 废弃聚苯乙烯塑料在环境与能源中的高值化应用进展[J]. 化工学报, 2020, 71(7): 2956-2972.
[10] 王鹏, 刘京雷, 张胜中, 范得权, 张英, 徐宏. 结构化5A分子筛吸附床结构及工艺参数对N2/H2吸附性能的影响[J]. 化工学报, 2020, 71(7): 3114-3122.
[11] 牛敬苒, 邓会宁, 张伟, 胡柏松, 张少峰. 二氧化钛调控基膜结构对氧化石墨烯复合膜性能的影响[J]. 化工学报, 2020, 71(6): 2850-2856.
[12] 田济阳, 邹源佐, 蒲源, 王丹. 亚临界水耦合冷冻干燥法制备芹菜素纳米分散体[J]. 化工学报, 2020, 71(6): 2768-2779.
[13] 王雅倩, 鲁晓, 彭波. 磁场对(C4H9NH3)2(CH3NH3)Pb2I7钙钛矿发光特性调控的研究[J]. 化工学报, 2020, 71(6): 2912-2917.
[14] 鞠佳, 祁文旭, 孔鹏飞, 汤佳玉, 梁飞雪, 张晓欣, 贺高红, 杨磊. TiO2/PVDF共混微滤膜的制备及其吸附胆红素的研究[J]. 化工学报, 2020, 71(6): 2705-2712.
[15] 王永胜, 兰小林, 邱天, 张新平, 吴莹莹, 陈莉, 徐伟祥, 郭栋杰, 段正康. 铜基石墨烯复合催化剂的合成与表征[J]. 化工学报, 2020, 71(6): 2889-2899.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
[1] K. Rajagopal, S. S. Jayabalakrishnan. Effect of Temperature on Volumetric and Viscometric Properties of Homologous Amino Acids in Aqueous Solutions of Metformin Hydrochloride[J]. CIESC Journal, 2010, 18(3): 425 -445 .
[2] 王斌,陈继,安振涛,刘会洲. 自吸式相分散方法研究乳化破乳过程 [J]. CIESC Journal, 2000, 51(S1): 252 -255 .
[3] 杜佩衡;董艳河;王荣良;黄敬.

梯矩形立体连续传质塔板流体力学性能

[J]. CIESC Journal, 2005, 56(4): 593 -597 .
[4] 陈卫东, Patil S.L., Kamath V.A., Chukwu G.A.. 卵磷脂对甲烷水合物形成的影响 [J]. 化工学报, 2007, 58(11): 2895 -2900 .
[5] 任丹萍, 段谟华, 张国亮, 孟琴, 杨志宏, 吴景. 填充密度对中空纤维膜接触器精馏过程壳程传质的影响 [J]. 化工学报, 2009, 60(9): 2226 -2231 .
[6] 夏国栋, 柴磊, 杨瑞波, 周明正. 周期性变截面微通道结构参数对流体流动和传热的影响 [J]. 化工学报, 2009, 60(11): 2705 -2711 .
[7] 曹东旭;乔斌;葛志强;元英进.

多烯紫杉醇诱导细胞周期阻断与凋亡过程的模型

[J]. CIESC Journal, 2005, 56(5): 904 -910 .
[8] 沈九宾, 陈海耿, 陈婉. 用离散传递法求解辐射全交换面积 [J]. 化工学报, 2003, 54(12): 1674 -1677 .
[9] 陈光文, 袁权. 微化工技术 [J]. 化工学报, 2003, 54(4): 427 -439 .
[10] 杨国刚;丁信伟;毕明树.

聚乙烯薄膜对可燃气云爆炸影响的实验研究与数值模拟

[J]. CIESC Journal, 2005, 56(1): 180 -184 .