双级燃料反应器的煤化学链燃烧特性

doi:10.11949/j.issn.0438-1157.20180249

摘要/Abstract

摘要：

在5 kW_th双级燃料反应器的化学链燃烧装置上，开展煤化学链燃烧特性研究，重点考察反应温度和气化介质对燃烧补偿率、碳增补率、出口气体组分浓度、额外耗氧率以及碳捕集效率的影响规律。实验结果表明，较高的反应温度能显著提高燃烧效率，900℃时出口烟气中CO₂浓度可达92.1%；随着反应温度升高，碳捕集率和燃烧补偿率分别上升至99.6%和83.4%，额外耗氧率和碳增补率下降至12.1%和4.8%。以CO₂为气化介质时，整体反应效率有大幅下降，额外耗氧率提高至23%。此外，在Ⅰ级FR反应器内发现有少量的团聚颗粒，但并未对流化产生影响。

关键词: 二氧化碳捕集, 化学反应器, 双级燃料反应器, 煤燃烧, 气化介质

Abstract:

A 5 kW_th two-stage fuel reactor of chemical looping combustion facility was successfully built to carry out the characteristic research of coal chemical looping combustion. The experiment focused on the influence of temperature and gasifying agent on the combustion compensation efficiency, carbon supplementation, outlet gas component, oxygen demand and carbon capture efficiency. The results showed that high temperature can significantly improve the combustion efficiency in which the CO₂ concentration was up to 92.1% at 900℃. With the increase of temperature, CO₂ capture efficiency and combustion compensation efficiency increased to 99.6% and 83.4% respectively, while the oxygen demand and carbon supplementation decreased to 12.1% and 4.8%. The CO₂ serving as gasifying agent had an adverse effect on reaction efficiency that the oxygen demand was increased to 23%. In addition, there was a small amount of particles agglomeration in FR-Ⅰ, but had a limited influence on fluidization.

Key words: CO₂ capture, chemical reactors, two-stage fuel reactor, coal combustion, gasifying agent

中图分类号:

TQ534.9

沈天绪, 吴建, 闫景春, 沈来宏. 双级燃料反应器的煤化学链燃烧特性[J]. 化工学报, 2018, 69(9): 3965-3974.

SHEN Tianxu, WU Jian, YAN Jingchun, SHEN Laihong. Chemical looping combustion of coal in a two-stage fuel reactor[J]. CIESC Journal, 2018, 69(9): 3965-3974.

参考文献 30

[1]	FAN L S, LI F X, RAMKUMAR S, et al. Utilization of chemical looping strategy in coal gasification processes[J]. Particuology, 2008, 6(3):131-142.
[2]	刘永卓, 郭庆杰. 化学链基础理论及其在节能减排中的应用[J]. 工程研究-跨学科视野中的工程, 2015, 7(4):404-412. LIU Y Z, GUO Q J. Basic theory of chemical looping and application of energy saving and emission reduction[J]. Journal of Engineering Studies, 2015, 7(4):404-412.
[3]	王保文, 赵海波, 郑瑛, 等. 煤化学链燃烧技术的研究进展[J]. 动力工程学报, 2011, 31(7):544-550. WANG B W, ZHAO H B, ZHENG Y, et al. Research progress in chemical looping combustion of coal[J]. Journal of Chinese Society of Power Engineering, 2011, 31(7):544-550.
[4]	BAO J H, LI Z S, CAI N S. Promoting the reduction reactivity of ilmenite by introducing foreign ions in chemical looping combustion[J]. Industrial & Engineering Chemistry Research, 2013, 52(18):6119-6128.
[5]	ADANEZ J, ABAD A, GARCIA L F, et al. Progress in chemical-looping combustion and reforming technologies[J]. Progress in Energy & Combustion Science, 2013, 38(2):215-282.
[6]	ADANEZ J, DUESO C, DIEGO L F D, et al. Methane combustion in a 500 Wth chemical-looping combustion system using an impregnated Ni-based oxygen carrier[J]. Fuel, 2009, 88(12):2357-2364.
[7]	MARKSTROEM P, LINDERHOLM C, LYNGFELT A, et al. ChemInform abstract:chemical-looping combustion of solid fuels-design and operation of a 100 kW facility with bituminous coal[J]. ChemInform, 2013, 15(12):150-162.
[8]	CHENG M, SUN H, LI Z, et al. Annular carbon stripper for chemical-looping combustion of coal[J]. Industrial & Engineering Chemistry Research, 2017, 56(6):1580-1593.
[9]	马吉亮, 刘道银, 梁财, 等. 黏性Geldart B类颗粒流化特性实验研究[J]. 工程热物理学报, 2017, 38(8):1702-1706. MA J L, LIU D Y, LIANG C, et al. Experimental study on the fluidization dynamics of cohesive Geldart B particles[J]. Journal of Engineering Thermophysics, 2017, 38(8):1702-1706.
[10]	STROHLE J, ORTH M, EPPLE B. Design and operation of a 1 MWth, chemical looping plant[J]. Applied Energy, 2014, 113(C):1490-1495.
[11]	Lyngfelt A. Chemical-looping combustion of solid fuels-status of development[J]. Applied Energy, 2014, 113(1):1869-1873.
[12]	Vilches T B, Lind F, RydEn M, et al. Experience of more than 1000 h of operation with oxygen carriers and solid biomass at large scale[J]. Applied Energy, 2017, 190(3):1174-1183.
[13]	Adanez J, Abad A, Mendiara T, et al. Chemical looping combustion of solid fuels[J]. Progress in Energy & Combustion Science, 2018, 65(3):6-66.
[14]	Kim H R, Wang D, Zeng L, et al. Coal direct chemical looping combustion process:design and operation of a 25 kWth, sub-pilot facility[J]. Fuel, 2013, 108(11):370-384.
[15]	Thon A, Kramp M, Hartge E U, et al. Operational experience with a system of coupled fluidized beds for chemical looping combustion of solid fuels using ilmenite as oxygen carrier[J]. Applied Energy, 2014, 118(1):309-317.
[16]	Shen L H, Wu J H, Gao Z P, et al. Reactivity deterioration of NiO/Al2O3, oxygen carrier for chemical looping combustion of coal in a 10 kWth, reactor[J]. Combustion & Flame, 2009, 156(7):1377-1385.
[17]	Penthor S, Stollhof M, Proll T, et al. Detailed fluid dynamic investigations of a novel fuel reactor concept for chemical looping combustion of solid fuels[J]. Powder Technology, 2016, 287(1):61-69.
[18]	Lin S Y, Saito T, Hashimoto K. Development of the three-tower chemical looping coal combustion technology[J]. Energy Procedia, 2017, 114(7):414-418.
[19]	Abad A, Adanez R I, Gayan P, et al. Demonstration of chemical-looping with oxygen uncoupling (CLOU) process in a 1. 5 kWth continuously operating unit using a Cu-based oxygen-carrier[J]. International Journal of Greenhouse Gas Control, 2012, 6(6):189-200.
[20]	Abad A, Perez V R, Diego L F, et al. Design and operation of a 50 kWth, chemical looping combustion (CLC) unit for solid fuels[J]. Applied Energy, 2015, 157(11):295-303.
[21]	闫景春, 沈来宏. 基于燃料氧化分级的化学链燃烧冷态实验研究[J]. 工程热物理学报, 2017, 38(3):665-671. Yan J C, SHEN L H. Experimental study on the cold model of the chemical-looping combustor based on step oxidation of fuel[J]. Journal of Engineering Thermophysics, 2017, 38(3):665-671.
[22]	Adanez J, Cuadrat A, Abad A, et al. Ilmenite activation during consecutive redox cycles in chemical-looping combustion[J]. Energy & Fuels, 2013, 24(2):1402-1413.
[23]	Garcia L F, Diego L F D, Adanez J, et al. Temperature variations in the oxygen carrier particles during their reduction and oxidation in a chemical-looping combustion system[J]. Chemical Engineering Science, 2005, 60(3):851-862
[24]	Cuadrat A, ABAD A, Garcia L F, et al. The use of ilmenite as oxygen-carrier in a 500 W chemical-looping coal combustion unit[J]. International Journal of Greenhouse Gas Control, 2011, 5(6):1630-1642.
[25]	张成. CO与CO2甲烷化反应研究进展[J]. 化工进展, 2007, 26(9):1269-1273. ZHANG C. Research progress of methanation of carbon monoxide and carbon dioxide[J]. Chemical Industry and Engineering Process, 2007, 26(9):1269-1273.
[26]	Moilanen A, Muhlen H J. Characterization of gasification reactivity of peat char in pressurized conditions:effect of product gas inhibition and inorganic material[J]. Fuel, 1996, 75(11):1279-1285.
[27]	Mattisson T, Johansson M, Lyngfelt A, et al. Multicycle reduction and oxidation of different types of iron oxide particles application to chemical-looping combustion[J]. Energy & Fuels, 2004, 18(3):628-637.
[28]	史奇良, 陈时熠, 薛志鹏, 等. 铁基载氧体化学链制氢特性实验研究[J]. 中国电机工程学报, 2011, 31(S1):168-174. SHI Q L, CHEN S Y, XUE Z P, et al. Experimental investigation of chemical looping hydrogen generation using iron oxides as oxygen carrier[J]. Proceedings of the CSEE, 2011, 31(S1):168-174.
[29]	万奇顺, 刘永卓, 郭庆杰, 等. 煤焦化学链气化过程中神木煤灰对铁基载氧体反应特性及结构的影响[J]. 过程工程学报, 2017, 17(5):995-1001. WAN Q S, LIU Y Z, GUO Q J, et al. Influence of Shenmu coal ash on the reaction characteristics and structure of Fe-based oxygen carrier in coal char chemical looping gasification[J]. The Chinese Journal of Process Engineering, 2017, 17(5):995-1001.
[30]	石司默, 董长青, 覃吴, 等. Fe2O3/粉煤灰载氧体化学链燃烧实验与机理研究[J]. 化工学报, 2012, 63(12):4010-4018. SHI S M, DONG C Q, QIN W, et al. Experimental and theoretical oxygen carrier in study of Fe2O3/coal ash CLC system[J]. CIESC Journal, 2012, 63(12):4010-4018.